【摘要】：消炎痛,又稱為吲哚美辛,英文名為:Indomethacin,是一種具有抑制環氧酶的作用致使前列腺素的合成減少以達到抗炎、鎮痛、解熱作用的非甾體抗炎藥,分子式:C19H16ClnO4,在其重氮、�；�、合環、精致等生產過程中,產生了大量制藥廢水,該廢水成分復雜,處理難度大。本課題目的是針對石家莊經濟技術開發區某企業消炎痛生產廢水濃度高,色度深、處理難度大的特點,在經過中試的基礎上,進行了工程工藝設計和運行控制研究,希望對消炎痛廢水的處理提供一些參考。預處理實驗表明,采用PAC(聚合氯化鋁)、PAM(聚丙烯酰胺)作為最佳混凝劑,最佳投加量分別為200 mg/L和0.8 mg/L,進水指標COD5000~5500 mg/L,SS2500-3000 mg/L,出水COD、SS為3500-3850 mg/L和300~360 mg/L,COD、SS去除率為30%和88%,為后續處理打下良好基礎。通過方案對比,確定“均質調節—預曝氣池—混凝沉淀—ABR—SBR—BAF”為處理工藝方案。經過調試與穩定運行數據分析,工程日處理廢水1000 m3/d,處理后的COD、氨氮去除效率可達99%,達到要求的設計排放標準,運行效果良好,出水水質滿足石家莊經濟技術開發區污水處理廠污水接納協議標準。項目占地面積為2474 m2,總投資2043.11萬元,年運行費用為764.85萬元/a,運行成本為25.495元/噸。研究結果表明,論文提出的組合工藝對消炎痛廢水處理經濟有效,技術可行。
[Abstract]:Indomethacin, also known as indomethacin, is a nonsteroidal anti-inflammatory drug with an inhibitory effect on cyclooxygenase that reduces the synthesis of prostaglandins to achieve anti-inflammatory, analgesic, and antipyretic effects, with the molecular formula: C19H16ClnO4, in its diazo, acylation, and ring. A large amount of pharmaceutical wastewater is produced in the process of delicate production, which is difficult to treat because of its complex composition. In view of the characteristics of high concentration, deep chroma and difficulty in treatment of indomethacin wastewater in a certain enterprise in Shijiazhuang Economic and technological Development Zone, the engineering process design and operation control are studied on the basis of pilot test. It is hoped to provide some references for the treatment of indomethacin wastewater. The pretreatment experiment showed that PAC (polyaluminum chloride) PAM (polyacrylamide) was used as the best coagulant. The optimal dosages are 200 mg / L and 0.8 mg / L, respectively. The influent index COD5000 ~ 5500 mg / L is 2500-3000 mg / L, the effluent CODSS is 3500-3850 mg / L and the removal rate of 300-360 mg / L / L CODSS is 30% and 88% respectively, which lays a good foundation for the follow-up treatment. The homogenization adjustment-pre-aeration tank-coagulation sedimentation-ABR-SBR-BAF was selected as the process plan. After debugging and stable operation data analysis, the waste water is treated by 1000 m3 / d per day. After treatment, the removal efficiency of ammonia nitrogen can reach 99%, which meets the required design discharge standard, and the operation effect is good. The effluent quality meets the agreement standard of sewage treatment plant in Shijiazhuang Economic and technological Development Zone. The area of the project is 2474 m2, the total investment is 20.4311 million yuan, the annual operating cost is 7.6485 million yuan / a, and the operating cost is 25.495 yuan / ton. The results show that the combined process proposed in this paper is economical, effective and feasible for indomethacin wastewater treatment.
【學位授予單位】：河北科技大學
【學位級別】：碩士
【學位授予年份】：2017
【分類號】：X787

【參考文獻】

相關期刊論文 前10條

1 陳斌;曾桂華;;電解法處理高濃度有機磷農藥廢水COD去除率的影響研究[J];化工管理;2016年31期

2 姚遠;;A/O+MBR工藝在生活污水處理站中的應用[J];給水排水;2016年S2期

3 楊鑫國;左金龍;陳大祥;王笑悅;王雪薇;穆德穎;;SBR法對模擬乳制品廢水處理的效果影響[J];科技展望;2016年26期

4 徐鵬;戰友;張萬昌;王廣智;;水解酸化-生物接觸氧化工藝處理中草藥廢水啟動特性研究[J];化學與黏合;2016年04期

5 王白楊;吳星;羅亞情;劉英輝;;物化+生化工藝在高氮高磷制藥廢水處理中的應用[J];工業水處理;2015年12期

6 崔鳳國;楊鵬;張偉軍;王東升;;混凝和活性炭吸附深度處理制藥廢水中有機物去除特征[J];環境工程學報;2015年09期

7 李亞峰;高穎;;制藥廢水處理技術研究進展[J];水處理技術;2014年05期

8 徐珊姍;;探討醫藥化工廢水處理技術應用問題及解決方法[J];化工管理;2014年15期

9 魏錚;龐維亮;馮麗霞;;AB法污水處理工藝處理制藥廢水的應用實例[J];資源節約與環保;2014年03期

10 時永輝;蘇建文;陳建華;許尚營;王俊超;王彩冬;鄭浩;賈秀粉;;微電解-Fenton深度處理制藥廢水影響因素與參數控制[J];環境工程學報;2014年03期

相關碩士學位論文 前2條

1 李紅云;微泡對水處理的作用機理及應用研究[D];昆明理工大學;2014年

2 張小璇;染料廢水的活性炭吸附及其熱再生研究[D];廈門大學;2005年

，

本文編號：2130171