本文關鍵詞： 電除塵器 頂部電磁振打 側部機械振打 振打加速度 電場參數 PM PM.　出處：《高電壓技術》2017年02期 　論文類型：期刊論文

【摘要】：振打清灰過程是電除塵器(ESP)持續高效運行的一項重要保障,電極表面清灰效果直接影響電除塵器運行電氣參數,進而影響電除塵器的粉塵排放質量濃度。為此,以有功功率為600 MW的燃煤機組雙室5電場工業電除塵器為例,對比分析了頂部電磁振打和側部機械振打?qū)﹄姵龎m器運行參數以及排放質量濃度的影響。結果表明:在相同振打參數條件下,側部機械振打產生的加速度平均值約為頂部電磁振打的3倍,而且振打加速度分布相對均勻;通過將頂部電磁振打改造為側部機械振打,電除塵器每個通道的電源輸入容量由131 kVA提高至190kVA;PM10排放質量濃度由19.33 mg/m3降低至14.14 mg/m3,降低比例為26.85%;PM2.5排放質量濃度由4.23mg/m3降低至1.20 mg/m3,降低比例為71.53%。電除塵器處理高黏性、高比電阻的粉塵時采用側部機械振打有利于提高電除塵器運行參數并降低電除塵器出口粉塵排放質量濃度。
[Abstract]:Vibration cleaning process is an important guarantee for ESPs to run continuously and efficiently. The cleaning effect of electrode surface directly affects the electrical parameters of ESP. Thus, the dust emission mass concentration of the electrostatic precipitator is affected. For this reason, the duplex chamber 5 electric field industrial electrostatic precipitator with 600 MW active power is taken as an example. The effects of the top electromagnetic vibration and the lateral mechanical vibration on the operation parameters and emission mass concentration of the electrostatic precipitator are compared and analyzed. The results show that: under the same vibration parameters. The average acceleration produced by the lateral mechanical vibration is about three times that of the top electromagnetic vibration, and the acceleration distribution is relatively uniform. By transforming the top electromagnetic vibration into the side mechanical vibration, the power input capacity of each channel of the electrostatic precipitator is increased from 131 kVA to 190kVA. The emission concentration of PM10 was reduced from 19.33 mg/m3 to 14.14 mg / m ~ (3), and the ratio of reduction was 26.85%. The emission mass concentration of PM2.5 was reduced from 4.23 mg / m ~ 3 to 1.20 mg / m ~ (3), and the ratio was 71.53. The electrostatic precipitator was used to treat high viscosity. The use of lateral mechanical vibration in the dust with high specific resistance can improve the operating parameters of the electrostatic precipitator and reduce the dust emission concentration at the outlet of the electrostatic precipitator.
【作者單位】： 浙江大學化學工程與生物工程學院工業生態與環境研究所;
【基金】：國家高技術研究發展計劃(863計劃)(2013AA 0651001-1)~~
【分類號】：X773
【正文快照】： 0引言1工業電除塵器(ESP)種類和結構形式繁多,但是都基于相同的工作原理,主要包括電暈放電、粉塵荷電、荷電粉塵在電場中的遷移運動以及被捕集粉塵的清除[1-3]。工業電除塵器通常采用負高壓直——流電暈,即在放電陰極線與接地陽極板之間施加一負直流高壓,放電陰極線周圍形成大

【參考文獻】

相關期刊論文 前10條

1 梁志宏;李栓寶;陳俊峰;張金海;陳寶瑞;薛祥忠;王仕龍;閆克平;;燃煤電廠電除塵PM_(10)和PM_(2.5)的排放控制Ⅶ:以2×600MW機組為例分析討論電除塵選型和改造[J];科技導報;2016年05期

2 馬洪金;徐建元;王仕龍;韓平;鄭欽臻;李樹然;閆克平;;燃煤電廠電除塵PM_(10)和PM_(2.5)的排放控制Ⅵ:以75t/h工業鍋爐為例分析討論電除塵的運行(嘉興協鑫環保熱電分析)[J];科技導報;2015年18期

3 閆克平;李樹然;馮衛強;鄭欽臻;杜艷艷;沈欣軍;戴紹龍;寇艷芹;徐羽貞;王仕龍;韓平;朱安娜;馮文強;黃逸凡;劉振;;高電壓環境工程應用研究關鍵技術問題分析及展望[J];高電壓技術;2015年08期

4 馬元坤;秦松;陳亮;徐榮田;王仕龍;陳英;韓平;鄭欽臻;沈欣軍;李樹然;閆克平;;燃煤電廠電除塵PM_(10)和PM_(2.5)的排放控制V:以660 MW機組為例分析討論高壓電源運行優化[J];科技導報;2015年06期

5 沈欣軍;王仕龍;韓平;鄭欽臻;曾宇，

本文編號：1462110