本文選題：粉煤灰基多孔陶瓷 + 造孔劑��； 參考：《新型建筑材料》2017年07期

【摘要】：利用粉煤灰、赤泥為主要原料制備粉煤灰基多孔陶瓷,研究漂珠和氧化鋁空心球2種造孔劑對粉煤灰基多孔陶瓷的基本物性和微觀結構的影響。SEM顯示漂珠制備的粉煤灰基多孔陶瓷中漂珠大部分形成的是閉氣孔,而氧化鋁空心球顆粒外殼之間相互發生反應,晶體向空心球內部增長,形成較多的連通氣孔,影響其保溫性能和強度。在造孔劑摻量為15%時,漂珠制備的多孔陶瓷收縮率比氧化鋁空心球制備的低6.7%,氣孔率高3.7%,性能穩定。
[Abstract]:Fly ash based porous ceramics were prepared by using fly ash and red mud as main raw materials. The effect of two kinds of pore-making agents on the basic physical properties and microstructure of fly ash based porous ceramics. SEM shows that most of the floating beads are air-closed pores in the fly ash based porous ceramics prepared by drifter beads and alumina hollow spheres, and the effect of these two pore-making agents on the basic physical properties and microstructure of fly ash based porous ceramics is studied. However, the shell of alumina hollow spheres reacts with each other, and the crystal grows into the hollow spheres, forming more continuous air holes, which affect the thermal insulation performance and strength of alumina hollow spheres. When the amount of pore-forming agent is 15, the shrinkage of the porous ceramics prepared by bleach beads is 6.7% lower than that prepared by alumina hollow spheres, and the porosity is 3.7. the properties of the porous ceramics are stable.
【作者單位】： 重慶交通大學土木工程學院;云南省建筑科學研究院;
【分類號】：TQ174.1

【相似文獻】

相關期刊論文 前5條

1 康慶慶;王慶偉;王勇峰;祝聿霏;;不同造孔劑對煤矸石合成多孔莫來石性能影響的研究[J];中國陶瓷;2012年06期

2 梁小平,靳正國,朱春華,胡在華;造孔劑對多孔Al_2O_3陶瓷性能的影響[J];天津工業大學學報;2005年03期

3 伍協;陳振華;馮延林;劉小磐;李秀莉;;采用布纖維做造孔劑制備微蜂窩陶瓷(英文)[J];Transactions of Nonferrous Metals Society of China;2011年12期

4 李娜,王超,朱蘇敏,王若釘;聚乙二醇作造孔劑制備大孔溶膠凝膠生物活性玻璃[J];無機化學學報;2005年01期

5 于波;張文強;梁明德;張平;徐景明;;PMMA造孔劑對固體氧化物電解池制氫性能的影響[J];無機材料學報;2011年08期

，

本文編號：1783757