本文選題：蒸汽回轉干燥機　切入點：脫硫石膏　出處：《哈爾濱工業大學》2015年碩士論文

【摘要】：在脫硫石膏資源化處置工藝中,蒸汽回轉干燥工藝以其優越性獲得石膏行業的認可。由于蒸汽回轉干燥機傳熱非常復雜,目前國內外尚無設計準則,相關的研究成果比較匱乏。通過理論分析和實驗研究的方法對蒸汽回轉干燥機的傳熱機理進行研究是極具價值的。分析了脫硫石膏蒸汽回轉干燥機理、換熱管傳熱過程和干燥機傳熱學參數對傳熱效果的影響,介紹了干燥機的主要特征參數和換熱管傳熱系數的一般計算方法以及方法中存在的問題。為分析脫硫石膏蒸汽回轉干燥機主要工藝參數對干燥傳熱的影響規律,設計了一套蒸汽回轉實驗系統,論述了實驗原理和實驗流程,并對實驗設備和儀表進行了標定。為準確獲得測量數據,設定了脫硫石膏蒸汽回轉實驗臺實驗參數,并通過對石膏粉顆粒在干燥機內六種狀態的分析,確定實驗轉速,同時設計了實驗臺熱損失的測定實驗、冷態實驗步驟和熱態干燥實驗步驟。利用脫硫石膏蒸汽回轉實驗臺進行了冷態和熱態共計54組實驗。為分析筒體轉速、物料填充率、換熱管位置、換熱管翅化對脫硫石膏蒸汽回轉干燥系統平均換熱系數和換熱管對物料作用時間的影響,對所得數據進行了分類和分析,獲得各因素對傳熱的影響曲線。
[Abstract]:In desulphurization gypsum resource treatment process, steam rotary drying process is recognized by gypsum industry for its advantages.Because the heat transfer of steam rotary dryer is very complex, there is no design criterion at home and abroad, and the related research results are scarce.It is very valuable to study the heat transfer mechanism of steam rotary dryer by means of theoretical analysis and experimental study.The mechanism of steam rotary drying of desulphurized gypsum, the effect of heat transfer process of heat transfer tube and the heat transfer parameters of dryer on the heat transfer effect are analyzed.This paper introduces the main characteristic parameters of dryer, the general calculation method of heat transfer coefficient of heat transfer pipe and the problems existing in the method.In order to analyze the influence of main technological parameters on drying heat transfer of desulphurized gypsum steam rotary dryer, a steam rotary experimental system was designed, the experimental principle and flow were discussed, and the experimental equipment and instrument were calibrated.In order to obtain the measurement data accurately, the experimental parameters of the desulfurized gypsum steam rotary test bench were set up, and the rotational speed of the experiment was determined by analyzing the six states of the gypsum powder particles in the dryer. At the same time, the experiment was designed to measure the heat loss of the test bench.Cold state experiment step and hot state drying experiment step.A total of 54 groups of experiments were carried out in cold and hot state by means of desulphurization gypsum steam rotary test bench.In order to analyze the effects of cylinder speed, material filling rate, heat transfer pipe position, fin of heat transfer pipe on average heat transfer coefficient and heat transfer pipe time of desulphurized gypsum steam rotary drying system, the data obtained are classified and analyzed.The influence curves of various factors on heat transfer are obtained.
【學位授予單位】：哈爾濱工業大學
【學位級別】：碩士
【學位授予年份】：2015
【分類號】：TQ177.375

【參考文獻】

相關期刊論文 前10條

1 吳靜;李選友;陳寶明;王瑞雪;高玲;;間接加熱式列管回轉干燥機傳熱系數的測試方法[J];化工進展;2014年09期

2 彭達順;霍慧芳;;蒸汽回轉干燥機在高硫鐵精礦干燥中的應用[J];河北化工;2012年09期

3 王洪學;;蒸汽管式回轉干燥機不凝氣的排放[J];通用機械;2012年03期

4 王聯盟;;燃煤火電廠脫硫石膏綜合利用途徑研究[J];企業技術開發;2011年21期

5 方文倉;周建中;施存有;樓珍干;;脫硫石膏綜合利用的關鍵工藝技術及裝備[J];新型建筑材料;2010年12期

6 李建超;;蒸汽加熱管式回轉煅燒技術在電廠脫硫石膏處置中的應用[J];華東電力;2010年07期

7 周建中;馮菊蓮;周夢文;楊青;鄧嬪;李拓;;煅燒設備對建筑石膏性能影響的探索研究[J];新型建筑材料;2010年06期

8 呂新宇;王猛;楊歡;邱滔;;間接換熱式列管回轉干燥機傳熱系數的研究[J];常州大學學報(自然科學版);2010年02期

9 李帥俊;譚鳳娟;蘭瑞勃;;環管分體式蒸汽回轉干燥機在煤調濕技術上的應用[J];干燥技術與設備;2010年01期

10 譚永鵬;白玉貞;;蒸汽管回轉干燥機在鉛精礦干燥中的應用[J];硫酸工業;2009年03期

相關博士學位論文 前1條

1 吳靜;間接加熱式列管回轉干燥機傳熱分析及實驗研究[D];山東大學;2014年

相關碩士學位論文 前4條

1 王飛;內熱式蒸汽回轉干燥機內流場溫度場數值模擬[D];東北大學;2011年

2 李勇;回轉窯內物料運動與傳熱特性分析[D];華中科技大學;2011年

3 劉占斌;翅片管換熱過程的數值模擬及實驗研究[D];西安理工大學;2008年

4 邢召良;大型蒸汽列管回轉干燥機干燥PTA傳熱機理的研究[D];天津大學;2008年

，

本文編號：1724342