【摘要】：對0.3 mol·L-1 Na OH改性后的HZSM-5以及未改性HZSM-5催化劑進行循環和再生評價實驗以考察催化劑的壽命。對反應后和再生的催化劑進行N2吸脫附以及NH3-TPD表征,并通過對反應后的催化劑進行SEM、TGA、FTIR、UV-Vis等表征分析催化劑積炭。兩種催化劑的活性均隨著循環實驗次數的增加而逐漸降低,經4次循環實驗的改性HZSM-5催化劑的催化活性遠高于4次循環實驗的未改性HZSM-5催化劑。反應過的催化劑經高溫煅燒再生后其活性都有所恢復,再生后的改性HZSM-5的催化活性仍高于未改性催化劑。對兩種不同催化劑積炭分析,改性后催化劑的積炭量少于未改性的催化劑,其積炭組分中高聚芳烴的含量相對較多。
[Abstract]:The cycle and regeneration experiments of HZSM-5 modified with 0.3 mol L-1 Na OH and unmodified HZSM-5 were carried out to investigate the lifetime of the catalyst. The catalyst after reaction and regeneration was characterized by N2 adsorption and desorption and NH3-TPD, and the catalyst was characterized by SEM,TGA,FTIR,UV-Vis. The activity of the two catalysts decreased gradually with the increase of the number of cycles. The catalytic activity of the modified HZSM-5 catalyst after four cycles was much higher than that of the unmodified HZSM-5 catalyst. The catalytic activity of the modified HZSM-5 was still higher than that of the unmodified catalyst after the catalyst was regenerated at high temperature. The results show that the carbon deposition of the modified catalyst is less than that of the unmodified catalyst, and the content of high polyaromatic hydrocarbon in the carbon component of the modified catalyst is relatively high.
【作者單位】： 鄭州大學化學與分子工程學院;天方藥業有限公司;河南省環境化學與低碳技術重點實驗室;
【基金】：河南省國際合作基金項目(172102410041)~~
【分類號】：O643.36

【相似文獻】

相關期刊論文 前10條

1 郭錫坤,林綺純,林維明;鏑對固體超強酸催化劑ZrO_2-Dy_2O_3/SO_4~(2-)-HZSM-5的酸性和穩定性的影響[J];分子催化;2000年04期

2 由宏君,徐春明,高金森;反應條件對HZSM-5基催化劑芳構化反應的研究進展[J];天然氣化工;2005年05期

3 郭錫坤,林綺純,林維明;固體超強酸催化劑ZrO_2-Dy_2O_3/SO_4~(2-)-HZSM-5的制備及結構性能關系的研究[J];分子催化;2000年05期

4 李海波;張陸e，

本文編號：2326082