本文關鍵詞：兩級刷式密封的流動計算與系統參數的配置研究　出處：《潤滑與密封》2017年10期 　論文類型：期刊論文

  更多相關文章： 刷式密封 級數 泄漏 叉排管束 計算流體力學

【摘要】：基于兩級刷式密封的刷絲束截面二維叉排管束模型,利用計算流體動力學(CFD)方法研究?jī)杉?jí)刷式密封刷絲束截面泄漏流的壓力和流速分布規律,分析級數和級間距對出口平均軸向流速的影響,以及上下游級刷絲排數對級間分壓比的影響規律。結果表明:上下游級刷絲排數相同時,兩級刷式密封存在級間壓力不均勻性,下游級承受的壓降要大于上游級承受的壓降,壓力增大會加劇級間壓力不均勻性;兩級刷式密封的泄漏量比單級的泄漏量要小,當級數大于3后泄漏量的減少量很小;增加上游級刷絲排數或者減少下游級刷絲排數能改善級間壓力不均勻性。
[Abstract]:Two brush seal bristle staggered two-dimensional model based on the use of computational fluid dynamics (CFD) method to study the two bristle brush seal section leakage flow pressure and velocity distribution, influence analysis of series spacing on export average axial velocity, and the upper and lower level bristle rows on effect of two-stage compression ratio. The results show that the upper and lower level brush rows at the same level two brush seal has level pressure unevenness, pressure drop downstream stage to bear greater than that of the upper level under increasing pressure, will aggravate the level pressure uniformity; leakage two brush seal leakage is smaller than the single stage, when the series more than 3 leakage reduction amount is very small; increase the upstream stage wire brush rows or reduce the downstream stage bristle rows can improve the inter stage pressure unevenness.

【作者單位】： 中國地質大學(北京)工程技術學院;清華大學摩擦學國家重點實驗室;
【分類號】：TH136
【正文快照】： )j縥縥縥縥縥縥，

本文編號：1427498