【摘要】：對負載復合金屬催化劑的活性半焦脫除煙氣中NO進行了非等溫動力學研究,并對其反應機制進行了探討.使用熱重分析儀進行程序升溫脫硝實驗,采用Flynn-Wall-Ozawa(FWO),Kissinger-Akahira-Sunose(KAS)和Coats-Redfen(CR)非等溫動力學方法,計算純活性半焦和負載金屬催化劑的活性半焦脫硝的表觀活化能.使用X射線衍射儀(XRD)對催化劑脫硝前后的金屬活性相進行了分析.結果表明:在活性半焦上負載銅鐵復合金屬催化劑后,降低了脫硝反應的表觀活化能、反應所需溫度和反應能耗;當活性半焦的碳轉化率≤0.3時,脫硝過程主要由化學反應控制,當碳轉化率0.3時,脫硝過程轉向擴散控制為主;通過XRD結果分析可知,金屬催化劑的低價態活性相具有較高的催化活性,隨著脫硝反應的進行,金屬活性相被氧化成為活性較低的高價態;復合金屬氧化物鐵酸銅能在反應過程中分解成為活性更高的金屬活性相,提高了脫硝性能.
[Abstract]:The non-isothermal kinetics of activated semi-coke removal of NO from flue gas by supported composite metal catalyst was studied and the reaction mechanism was discussed. The temperature programmed denitrification experiment was carried out by thermogravimetric analyzer. The apparent activation energy of denitrification of pure active char and supported metal catalyst was calculated by Flynn-Wall-Ozawa (FWO) Kissinger-Akahira-Sunose (KAS) and Coats-Redfen (CR) non-isothermal kinetic method. The active phase of the catalyst before and after denitrification was analyzed by X-ray diffractometer (XRD). The results show that the apparent activation energy of denitrification is reduced, the reaction temperature and energy consumption are reduced, and the carbon conversion of activated char is 鈮，

本文編號：2227028