溢流分流兩段旋流器分選分級效果試驗研究
發布時間：2018-08-10 20:45
【摘要】：基于多溢流管旋流器的概念,結合前人對煤泥旋流重選柱的研究,開發了一種新型兩段旋流器分選分級裝置,一段溢流經分流后一部分直接由一段溢流管排出,另一部分沿切線由側溢流出口進入二段旋流器進行再一次分級,可一次給料同時實現一段底流排矸,二段底流出精煤,一、二段溢流排細泥的目的。以麻家梁選煤廠粒度-3 mm煤泥為研究對象,分別對一段溢流管插入深度和側溢流連接口徑進行了試驗研究。結果表明:以上試驗條件對該裝置的分選分級效果均有顯著影響,要保證一段分選分級效果,溢流管插入深度不能超過套筒深度;過大的連接口徑會造成二段底流精煤灰分偏高和二段旋流器分級性能下降。
[Abstract]:Based on the concept of multi-overflow cyclone and combined with previous researches on coal slime cyclone, a new type of separation and classification device for two-stage cyclone is developed. One section of overflow is discharged directly by a section of overflow pipe after shunting. The other part of the tangent line from the side overflow outlet into the two-stage cyclone for another classification, can feed at the same time to achieve a section of bottom flow waste, two stage bottom flow out of clean coal, the first and second stage overflow discharge of fine mud purposes. Taking the size 3-mm slime of Majialiang Coal preparation Plant as the research object, the penetration depth and the side overflow connection caliber of a section of overflow pipe were studied. The results show that the experimental conditions above have a significant effect on the separation and classification effect of the device. To ensure the separation and classification effect of one stage, the insertion depth of the overflow pipe can not exceed the sleeve depth. Too large connecting caliber will result in high ash content of two-stage bottom flow clean coal and poor classification performance of two-stage hydrocyclone.
【作者單位】： 太原理工大學化學化工學院;太原理工大學礦業工程學院;
【分類號】：TD462
[Abstract]:Based on the concept of multi-overflow cyclone and combined with previous researches on coal slime cyclone, a new type of separation and classification device for two-stage cyclone is developed. One section of overflow is discharged directly by a section of overflow pipe after shunting. The other part of the tangent line from the side overflow outlet into the two-stage cyclone for another classification, can feed at the same time to achieve a section of bottom flow waste, two stage bottom flow out of clean coal, the first and second stage overflow discharge of fine mud purposes. Taking the size 3-mm slime of Majialiang Coal preparation Plant as the research object, the penetration depth and the side overflow connection caliber of a section of overflow pipe were studied. The results show that the experimental conditions above have a significant effect on the separation and classification effect of the device. To ensure the separation and classification effect of one stage, the insertion depth of the overflow pipe can not exceed the sleeve depth. Too large connecting caliber will result in high ash content of two-stage bottom flow clean coal and poor classification performance of two-stage hydrocyclone.
【作者單位】： 太原理工大學化學化工學院;太原理工大學礦業工程學院;
【分類號】：TD462
【參考文獻】
相關期刊論文 前10條
1 劉立文;;三角錐水介質旋流器粗煤泥分選工藝設計與應用[J];煤炭工程;2015年12期
2 位革老;;復合型煤泥旋流器分級分選效果試驗研究[J];煤炭科學技術;2014年08期
3 陸帥帥;呂憲俊;劉培坤;張彩娥;;粗煤泥回收和分選工藝應用現狀[J];選煤技術;2014年02期
4 崔廣文;趙輝;徐東升;張祥宇;;粗煤泥分選新工藝的探討[J];煤炭加工與綜合利用;2014年01期
5 位革老;劉文禮;梁鵬飛;祖?zhèn)?;復合型煤泥旋流器流場模擬[J];煤炭學報;2013年01期
6 黃文鋒;李振濤;余標飛;豆偉;;梁北選煤廠粗精煤回收工藝改造的實踐[J];煤炭工程;2010年08期
7 于進喜;劉文禮;姚嘉胤;耿建純;Q彌競，
本文編號：2176153
本文鏈接：http://sikaile.net/kejilunwen/kuangye/2176153.html
最近更新
教材專著
