本文關鍵詞：FESTO液壓系統振動特性的研究　出處：《北京林業大學》2011年碩士論文　論文類型：學位論文

  更多相關文章： 液壓系統 振動 LabVIEW8.5 隔振

【摘要】：液壓系統振動是普遍存在的現象。振動不僅影響相關設備的正常運行,還會產生噪聲污染。本課題的研究對象是實驗室內使用的FESTO教學液壓系統。這個系統的液壓泵站直接安裝在實驗室水磨石地面上,工作時會產生較大的振動和噪聲,嚴重影響其他實驗室和辦公室的工作,因此很有必要對它的振動特性進行研究,并在此基礎上采取合適的隔振減振措施。相關研究表明,液壓系統的振動主要包括機械結構的振動和液體介質工作產生的振動兩個方面。根據實驗室液壓系統的振動情況,確定了FESTO液壓系統的振動以機械結構振動為主,而液體介質產生的振動相對較弱。 研究表明,FESTO液壓系統的主要振動形式是受到簡諧力激勵而產生的線性受迫振動,論文建立了液壓系統的單自由度簡諧受迫振動力學模型,運用LabVIEW8.5軟件設計了振動測試程序,選用相應的測試設備,對系統進行了振動特性測試,并做了頻譜等分析。在測試結果的基礎上設計了橡膠隔振器,用于液壓系統的隔振減振處理,同時對橡膠隔振器性能參數進行了分析計算。 通過對比液壓系統隔振前后的振動情況和噪聲水平,證明橡膠隔振器具有一定的隔振效果,振動和噪聲有較大幅度的降低,對相鄰實驗室和辦公室已經沒有太大影響。
[Abstract]:The vibration of hydraulic system is a common phenomenon. Vibration not only affects the normal operation of related equipment. The research object of this subject is the FESTO teaching hydraulic system which is used in the laboratory. The hydraulic pump station of this system is installed directly on the terrazzo ground of the laboratory. It is necessary to study the vibration characteristics of other laboratories and offices because of the large vibration and noise. On this basis, appropriate vibration isolation measures are taken. The vibration of hydraulic system mainly includes two aspects: the vibration of mechanical structure and the vibration caused by the working of liquid medium. According to the vibration of hydraulic system in laboratory. It is determined that the vibration of FESTO hydraulic system is mainly mechanical structure vibration, but the vibration produced by liquid medium is relatively weak. The research shows that the main vibration form of FESTO hydraulic system is the linear forced vibration caused by simple harmonic force. The dynamic model of single degree of freedom harmonic forced vibration of hydraulic system is established in this paper. The vibration test program is designed by using LabVIEW8.5 software, and the vibration characteristic of the system is tested by selecting the corresponding test equipment. On the basis of the test results, the rubber vibration isolator is designed, which is used for the vibration isolation and vibration reduction of hydraulic system, and the performance parameters of the rubber isolator are analyzed and calculated. By comparing the vibration and noise level of the hydraulic system before and after vibration isolation, it is proved that the rubber vibration isolator has a certain isolation effect, and the vibration and noise are greatly reduced. It has had little impact on adjacent laboratories and offices.
【學位授予單位】：北京林業大學
【學位級別】：碩士
【學位授予年份】：2011
【分類號】：TH137

【參考文獻】

相關期刊論文 前8條

1 唐春麗,方開翔;充液管道的模態試驗分析[J];華東船舶工業學院學報(自然科學版);2002年01期

2 孫培林;冷卻用齒輪泵的振動特性研究[J];華東船舶工業學院學報;1995年03期

3 楊明,楊志剛,林祖森;加速度計輸出信號的信息組成[J];華北工學院學報;2000年01期

4 李宏男,閻石;中國結構控制的研究與應用[J];地震工程與工程振動;1999年01期

5 任建亭,姜節勝;輸流管道系統振動研究進展[J];力學進展;2003年03期

6 王樂勤,何秋良;管道系統振動分析與工程應用[J];流體機械;2002年10期

7 張景繪,李新民;主、被動振動控制一體化理論及技術(Ⅰ)——導論[J];強度與環境;2004年01期

8 丁康,張曉飛;頻譜校正理論的發展[J];振動工程學報;2000年01期

相關碩士學位論文 前3條

1 劉玉秋;虛擬振動測試分析系統的設計[D];華北電力大學（河北）;2004年

2 陳濤;虛擬振動測試分析系統的研究[D];河北工業大學;2002年

3 郭月強;振動信號的測試與分析及其軟件系統的開發[D];北京工業大學;2002年

，

本文編號：1429531