【摘要】：通過深過冷凝固實驗對Co-Ru包晶合金中不同相的析出及演化行為進行了研究。采用熔融玻璃凈化與循環過熱相結合的方法對該合金的深過冷實驗獲得了217 K(0.12 T L)的最大過冷度。結合經典形核理論的計算結果,在全過冷度范圍內ξ相始終作為先析相優先從熔體中析出。當過冷度(ΔT)小于臨界過冷度(ΔT*≈180 K)時,合金凝固組織表現為典型的包晶組織,此時包晶相的析出依賴于ξ相的形態改變;當ΔTΔT*時,雖然ξ相仍為先析相,但是包晶相α的析出不再依賴于ξ相,而是直接從過冷熔體中析出并與ξ相競爭長大。隨著過冷度的增大,包晶相的相對含量先增加后減少最后再次增加。
[Abstract]:The precipitation and evolution of different phases in Co-Ru peritectic alloy were studied by cryogenic solidification experiment. The maximum undercooling degree of 217K (0.12 T L) was obtained by the method of melting glass purification and cyclic overheating. Based on the calculation results of classical nucleation theory, 尉 phase is always precipitated from melt as the first phase in the range of total undercooling. When the undercooling degree (螖 T) is less than the critical undercooling degree (螖 T * 鈮，

本文編號：2172429