【摘要】：研究了可降解Zn-7Mg合金經不同時間熱處理后的顯微組織演變及耐蝕性能。設計了鋅鎂合金Zn-7Mg材料,通過改變熱處理時間獲得Mg_2Zn_(11)相。通過EDS和ICP確定了鋅鎂合金的成分,運用OM和SEM分析合金的微觀組織,利用XRD譜表征合金的物相組成,采用電化學方法測試合金的耐蝕性能。結果表明,Zn-7Mg合金在鑄態時主要由α-Zn和MgZn_2兩相組成,熱處理時包晶反應迅速發生。Zn-7Mg合金熱處理后的平衡組織為Mg_2Zn_(11)相和少量殘余的Mg Zn2相;電化學開路電位和電化學阻抗譜分析表明,Mg_2Zn_(11)在PBS溶液中的耐腐蝕性能較純Zn差,在實際生產中應避免Mg_2Zn_(11)的產生。
[Abstract]:The microstructure evolution and corrosion resistance of degradable Zn-7Mg alloy after different time heat treatment were studied. Zinc magnesium alloy Zn-7Mg material was designed and Mg_2Zn_ (11) phase was obtained by changing heat treatment time. The composition of zinc-magnesium alloy was determined by EDS and ICP, the microstructure of the alloy was analyzed by OM and SEM, the phase composition of the alloy was characterized by XRD spectrum, and the corrosion resistance of the alloy was measured by electrochemical method. The results show that the as-cast Zn-7Mg alloy is mainly composed of 偽-Zn and MgZn_2 phases, and the peritectic reaction occurs rapidly during heat treatment. The equilibrium structure of Zn-7Mg alloy after heat treatment is Mg_2Zn_ (11) phase and a small amount of residual Mg Zn2 phase. Electrochemical open-circuit potential and electrochemical impedance spectroscopy showed that the corrosion resistance of Mg_2Zn_ (11) in PBS solution was worse than that of pure Zn, and the production of Mg_2Zn_ (11) should be avoided in practical production.
【作者單位】： 中國科學院寧波工業技術研究院慈溪生物醫學工程研究所;重慶理工大學材料科學與工程學院;
【基金】：國家自然科學基金(51301193) 浙江省公益項目(2015C31031) 寧波市自然科學基金(2015A610070)~~
【分類號】：TG146.13;TG166.7
，

本文編號：2417196