發布時間：2018-12-14 14:43

【摘要】：針對鈦合金Ti6Al4V在不同溶液(NaCl、NaBr、KBr)和不同溶液質量分?jǐn)?shù)(6.5%、12.5%、18.5%)下的電化學腐蝕行為進行研究,得到了鈦合金腐蝕極化曲線和腐蝕動力學參數;根據掃描電鏡腐蝕圖像研究了鈦合金的電化學腐蝕機理;采用像素點覆蓋分形維數法對腐蝕坑的分形特征進行了計算,得到了腐蝕表面形貌與分形的關系.研究結果表明:相比在NaBr溶液和KBr溶液中,鈦合金在NaCl溶液中的活化范圍更寬,氧化溶解時間更長,差異效應明顯;相同質量分?jǐn)?shù)下鈦合金在NaBr溶液中的腐蝕性更強;隨著質量分?jǐn)?shù)增大,鈦合金在3種溶液中的分形維數逐步變化——在NaBr溶液中的分形維數最大,表面形貌更為復雜,在NaCl溶液中的分形維數最小,表面形貌比較平整.
[Abstract]:The electrochemical corrosion behavior of titanium alloy Ti6Al4V in different solution (NaCl,NaBr,KBr) and different solution mass fraction (6.5% and 12.5%) was studied. The corrosion polarization curve and corrosion kinetics parameters of titanium alloy were obtained. The electrochemical corrosion mechanism of titanium alloy was studied by scanning electron microscope (SEM), and the fractal characteristics of the corrosion pit were calculated by the method of pixel coverage fractal dimension, and the relationship between the morphology of the corrosion surface and the fractal was obtained. The results show that the activation range of titanium alloy in NaCl solution is wider than that in NaBr solution and KBr solution, and the oxidation dissolution time is longer, the difference effect is obvious, and the corrosion of titanium alloy in NaBr solution is stronger at the same mass fraction. With the increase of mass fraction, the fractal dimension of titanium alloy changes gradually in three kinds of solutions: the fractal dimension in NaBr solution is the largest, the surface morphology is more complex, and the fractal dimension in NaCl solution is the smallest, and the surface morphology is relatively flat.
【作者單位】： 南京航空航天大學江蘇省精密與微細制造技術重點實驗室;江蘇省數字化電化學加工重點實驗室;常州工學院機械與車輛工程學院;
【基金】：江蘇省自然科學基金面上項目(BK20161193) 江蘇省自然科學研究重大項目(15KJA460002) 江蘇省精密與微細制造技術重點實驗室開放基金資助項目~~
【分類號】：TG174.36

【相似文獻】

相關期刊論文 前10條

1 董連科;王曉偉;;分形維數與臨界擴展力[J];金屬學報;1990年02期

2 施紹裘;張懋炯;施國勇;;斷裂表面的分形維數及其測量[J];寧波大學學報(理工版);1992年02期

3 蘇輝,張玉貴,閻振h，

本文編號：2378778