丁辛醇廢銠催化劑消解液制備高純?nèi)然櫻芯?/H1>
發布時間：2018-04-24 14:30
本文選題：廢銠催化劑消解液 + 丁辛醇�。� 參考：《無機鹽工業》2017年11期
【摘要】：液相消解是回收丁辛醇銠催化劑廢液中銠的一種重要方法,通常消解液中除銠離子、氯離子外,還有硫酸根、磷酸根以及鐵、鎳、鈣等賤金屬離子。探索了一種丁辛醇廢銠催化劑消解液制備高純?nèi)然櫟墓に嚒Ｊ紫?消解液在一定條件下加入過量氯化鋇過濾除去硫酸根,濾液在一定條件下加入過量鉬酸銨過濾除去磷酸根,所得濾液調節酸度后經氫型陽離子交換樹脂除去Fe、Ni、Ca、Ba等陽離子雜質,蒸發濃縮干燥得到高純度三氯化銠,雜質元素總量小于0.05%(質量分?jǐn)?shù)),銠回收率大于99%。
[Abstract]:Liquid phase digestion is an important method to recover rhodium from the waste liquid of butyl octanol rhodium catalyst. Besides rhodium ion, chloride ion, sulfate radical, phosphate radical and base metal ions such as iron, nickel, calcium, etc. The preparation of high purity rhodium trichloride from spent rhodium catalyst solution with butyl octanol was studied. First of all, excess barium chloride filter is added to the solution under certain conditions to remove sulfate radical, and excess ammonium molybdate filter is added to the filtrate under certain conditions to remove phosphate radical. After adjusting the acidity of the filtrate, the cationic impurity such as Fegni and Caobium Ba were removed by hydrogen exchange resin, and the high purity rhodium trichloride was obtained by evaporating and drying. The total impurity content was less than 0.05 (mass fraction, the recovery rate of rhodium was greater than 99%).
【作者單位】： 中海油天津化工研究設計院有限公司;
【分類號】：TQ138.22
【相似文獻】
相關期刊論文 前5條
1 易蘭美,周秀清,張淑美;電化學溶解制取三氯化銠[J];無機鹽工業;1985年03期
2 廖秋玲,曲志平,姚文學;水合三氯化銠的開發研究[J];中國資源綜合利用;2000年11期
3 馬子川,張素坤;COD測定儀用消解液的配制與應用[J];中國給水排水;2002年10期
4 楊春吉;從廢銠催化劑中提取銠粉[J];貴金屬;2002年04期
5 周建略，陳耀強，李峻，張堰黎，龔茂初，，陳豫;金屬載體相互作用對銠催化劑上CO吸附態穩定性的影響[J];四川大學學報(自然科學版);1994年04期
本文編號：1797033
本文鏈接：http://sikaile.net/kejilunwen/huaxuehuagong/1797033.html
本文選題：廢銠催化劑消解液 + 丁辛醇�。� 參考：《無機鹽工業》2017年11期
【摘要】：液相消解是回收丁辛醇銠催化劑廢液中銠的一種重要方法,通常消解液中除銠離子、氯離子外,還有硫酸根、磷酸根以及鐵、鎳、鈣等賤金屬離子。探索了一種丁辛醇廢銠催化劑消解液制備高純?nèi)然櫟墓に嚒Ｊ紫?消解液在一定條件下加入過量氯化鋇過濾除去硫酸根,濾液在一定條件下加入過量鉬酸銨過濾除去磷酸根,所得濾液調節酸度后經氫型陽離子交換樹脂除去Fe、Ni、Ca、Ba等陽離子雜質,蒸發濃縮干燥得到高純度三氯化銠,雜質元素總量小于0.05%(質量分?jǐn)?shù)),銠回收率大于99%。
[Abstract]:Liquid phase digestion is an important method to recover rhodium from the waste liquid of butyl octanol rhodium catalyst. Besides rhodium ion, chloride ion, sulfate radical, phosphate radical and base metal ions such as iron, nickel, calcium, etc. The preparation of high purity rhodium trichloride from spent rhodium catalyst solution with butyl octanol was studied. First of all, excess barium chloride filter is added to the solution under certain conditions to remove sulfate radical, and excess ammonium molybdate filter is added to the filtrate under certain conditions to remove phosphate radical. After adjusting the acidity of the filtrate, the cationic impurity such as Fegni and Caobium Ba were removed by hydrogen exchange resin, and the high purity rhodium trichloride was obtained by evaporating and drying. The total impurity content was less than 0.05 (mass fraction, the recovery rate of rhodium was greater than 99%).
【作者單位】： 中海油天津化工研究設計院有限公司;
【分類號】：TQ138.22
【相似文獻】
相關期刊論文 前5條
1 易蘭美,周秀清,張淑美;電化學溶解制取三氯化銠[J];無機鹽工業;1985年03期
2 廖秋玲,曲志平,姚文學;水合三氯化銠的開發研究[J];中國資源綜合利用;2000年11期
3 馬子川,張素坤;COD測定儀用消解液的配制與應用[J];中國給水排水;2002年10期
4 楊春吉;從廢銠催化劑中提取銠粉[J];貴金屬;2002年04期
5 周建略，陳耀強，李峻，張堰黎，龔茂初，，陳豫;金屬載體相互作用對銠催化劑上CO吸附態穩定性的影響[J];四川大學學報(自然科學版);1994年04期
本文編號：1797033
本文鏈接：http://sikaile.net/kejilunwen/huaxuehuagong/1797033.html
最近更新
教材專著
