本文關鍵詞： 電解錳陽極液 鐵碳微電解 硒 提取　出處：《濕法冶金》2017年05期 　論文類型：期刊論文

【摘要】：研究了采用鐵碳微電解法從電解錳陽極液中提取硒,考察了攪拌速度、反應時間、反應溫度、鐵碳總質量濃度和鐵碳質量比對硒提取率和鐵溶出率的影響,分析對比了反應前后鐵屑表面特征。結果表明:硒提取率隨攪拌速度、反應時間、鐵碳總質量濃度增大而提高,而受反應溫度的影響較小;在鐵碳質量比為2∶1時,硒提取效果較好;鐵溶出率隨反應時間延長和反應溫度升高而提高,受攪拌速度和鐵碳質量比的影響不明顯;在攪拌速度200r/min、反應時間3h、反應溫度30℃、鐵碳總質量濃度3.0g/L、鐵碳質量比2∶1條件下,硒提取率達96.52%。
[Abstract]:The effects of stirring rate, reaction time, reaction temperature, total iron-carbon mass concentration and iron-carbon mass ratio on the extraction rate and iron dissolution rate of selenium from electrolytic manganese anode solution were studied. The surface characteristics of iron chips before and after reaction were analyzed and compared. The results showed that the extraction rate of selenium increased with agitation speed, reaction time and total iron and carbon concentration, but was less affected by reaction temperature. When the iron-carbon mass ratio is 2: 1, the effect of selenium extraction is better. The dissolution rate of iron increased with the prolongation of reaction time and the increase of reaction temperature, but was not affected by the stirring speed and the ratio of iron to carbon. Under the conditions of stirring speed 200 r / min, reaction time 3 h, reaction temperature 30 鈩，

本文編號：1490582