本文關鍵詞：煤基合成氣甲烷化反應過程的熱力學計算與分析　出處：《化學工程》2016年11期 　論文類型：期刊論文

  更多相關文章： 替代天然氣 甲烷化反應 二氧化碳 熱力學分析 合成氣

【摘要】：建立了煤基合成氣甲烷化反應過程基于吉布斯自由能最小法的熱力學計算模型�？疾炝藴囟�、壓力對CO,CO_2單獨及同時甲烷化反應的影響,探討了原料氣脫碳處理后,CO_2摩爾分?jǐn)?shù)對CO轉化率、CH_4選擇性、CH_4產率及積炭的影響。結果表明,低溫高壓有利于甲烷化反應。在多數情況下CO轉化率要高于CO_2,尤其是溫度低于600℃時,CO甲烷反應比CO_2更容易發生;隨著溫度進一步升高,CO_2轉化率明顯上升,而CO轉化率迅速下降。另外,當原料氣中CO_2摩爾分?jǐn)?shù)低于2.44%時對積炭無影響,對CH_4的選擇性和產率降幅小于10%,在脫碳工藝中可以不予脫除。
[Abstract]:A thermodynamic model for the methanation reaction of coal-based syngas was established based on Gibbs free energy minimization method. The effects of temperature and pressure on the methanation of COG _ 2 were investigated. The effect of CO _ 2 molar fraction on CO conversion and Ch _ 4 selective Ch _ 4 yield and carbon deposition after decarburization of feedstock gas was investigated. In most cases, CO conversion is higher than COCO2, especially when the temperature is below 600 鈩，

本文編號：1431316