本文關鍵詞：WMS的玻璃藥瓶內氧氣含量檢測及其標定方法改進　出處：《光譜學與光譜分析》2017年10期 　論文類型：期刊論文

  更多相關文章： 波長調制光譜 二次諧波 半高譜峰面積 氧氣濃度

【摘要】：應用激光波長調制光譜(WMS)技術,建立了一種開放光路短光程檢測玻璃藥瓶內氧氣含量的方法。選擇氧氣分子位于760.885(13 142.58cm-1)的吸收譜線,通過多次調試優化了系統相關參數,給出了實時扣背景及實時譜線校正等數據處理的方法和步驟。采集七種不同氧氣含量的玻璃藥瓶樣本,獲取相應的二次諧波信號,分別建立二次諧波峰值、半高譜峰面積與濃度的線性回歸方程進行定量預測。實驗結果表明,其擬合系數分別為0.996 6和0.997 8,后者相比前者的標定方法提高了0.12%。采用完全交互驗證的方法來評價兩個模型的預測精度,其預測的均方根誤差(RMSEP)分別是0.003 1和0.002 0,后者相比前者降低了37.69%。對濃度是4%的氣體樣品,比較不同時間的20次測量結果,標準差分別為0.002 2和0.0016,后者相比前者降低了27.3%,同時其測量靈敏度分別為0.198%和0.097%,后者相比前者的靈敏度提高了約51%。證明了該系統及數據處理方法對玻璃藥瓶內氧氣含量檢測是可行的,且利用半高譜峰面積更豐富的幅值信息來反演氣體濃度可以降低波峰失真影響,檢測精度更高,穩定性更好。
[Abstract]:Application of laser wavelength modulation spectroscopy (WMS) technology, a new method of open path detection of glass bottle with short path oxygen content. Oxygen molecules within the 760.885 (13 142.58cm-1) absorption lines, through repeatedly debugging the system parameters optimization is given in real time and real-time deducting background spectrum correction data the processing method and the acquisition of seven different steps. The oxygen content of glass bottle samples, obtaining two harmonic signal corresponding to the establishment of the two harmonic peak, respectively, semi Pufeng area and high concentration linear regression equation for quantitative prediction. Experimental results show that the fitting coefficients were 0.9966 and 0.9978, compared with the former. The calibration method can improve the prediction accuracy of 0.12%. to evaluate the two methods using full cross validation of the model, the root mean square error of prediction (RMSEP) were 0.0031 and 0.0020, the latter than before The 37.69%. is a gas sample of 4% concentration, 20 measurements in different time, the standard deviation is 0.0022 and 0.0016, compared with the former decreased by 27.3%, while its sensitivity were 0.198% and 0.097%, compared with the former sensitivity increased about 51%. proved the system and data processing method the feasibility of detection of oxygen content in the glass bottle, and the use of high Pufeng area half amplitude information more abundant to retrieve the gas concentration can reduce wave distortion, higher detection accuracy and better stability.

【作者單位】： 中南大學信息科學與工程學院;湖南人文科技學院信息學院;
【基金】：國家自然科學基金重點項目(61533021);國家自然科學基金創新研究群體科學基金項目(61621062);國家自然科學基金項目(61773403) 湖南省教育廳重點項目(17A109)資助
【分類號】：TN249;TQ460.69
【正文快照】： 引　言　　在制藥行業中,密封玻璃藥瓶內的氧氣含量直接決定藥品的氧化速度,影響保質期,目前我國除極少數制藥企業引進國外先進檢測裝備在線檢測外,其他企業都是采用基于氣相色譜原理、電化學原理或磁氧分析等方法和手段進行抽樣檢測。隨著半導體激光器的發展,波長調制光譜(wa，

本文編號：1383198