【摘要】：首先建立了含橫向開閉裂紋Jeffcott轉子的運動方程,在此基礎上,利用非線性振動理論的多尺度分析方法,研究了過程中非共振區的開閉裂紋轉子振動特性。在模擬試驗臺上驗證了裂紋參數、裂紋方向及不平衡量大小對含裂紋轉子振動行為的關系,研究結果表明:在非共振轉速區,裂紋轉子的動平衡位置、基頻均隨裂紋深度而變化,裂紋越深影響越大;當不平衡量較小時,可以認為不平衡量與裂紋的相互作用僅對基頻分量有影響,對高階倍頻影響很小;不平衡量與裂紋法向的相位角對各階倍頻振幅的影響非常顯著,一般都是在0°或180°附近取得極值。
[Abstract]:Firstly, the motion equation of Jeffcott rotor with transverse open and closed cracks is established. On this basis, the vibration characteristics of open and closed cracked rotor in non-resonant region are studied by using the multi-scale analysis method of nonlinear vibration theory. The relationship between crack parameters, crack direction and unbalance on the vibration behavior of cracked rotor is verified on the simulation test-bed. The results show that the dynamic equilibrium position and fundamental frequency of cracked rotor vary with crack depth in the non-resonant speed region, and the deeper the crack is, the greater the influence is. When the unbalance is small, it can be considered that the interaction between unbalance and crack only affects the fundamental frequency component, but has little effect on high-order frequency doubling. The effect of the phase angle between the unbalance and the normal direction of the crack on the frequency doubling amplitude of each order is very significant, and the extreme value is usually obtained near 0 擄or 180 擄.
【作者單位】： 大連民族學院機械系;杭州電子科技大學機械工程學院;
【基金】：中央高校基本科研業務費專項資金項目:切削加工過程中顫振的診斷與識別方法研究(DC201502010305)
【分類號】：TH113.1

【相似文獻】

相關期刊論文 前10條

1 陳志明;;談對轉子動平衡檢驗技術分析[J];China's Foreign Trade;2010年12期

2 譚興斌;興成宏;李迎麗;李r，

本文編號：2500960