發布時間：2019-03-11 14:29

【摘要】：從液體靜壓導軌系統全局的角度出發,研究負載因素對其性能的影響。利用液阻網絡理論,綜合考慮油液黏溫效應,推導關聯參數與負載因素之間的數學關系,建立基于關聯參數的CFD求解計算模型;在不同負載因素條件下,根據攝動理論,使用Fluent動網格技術求解導軌系統的性能參數,進而研究其在脈沖載荷下的振動性能。研究結果表明:負載因素與初始?jí)毫Ρ葘?duì)導軌系統的性能參數產生影響,當負載比越大時,系統流量、固有頻率和最大振幅就越小,同時阻尼與阻尼比就越大;系統剛度則主要隨初始?jí)毫Ρ仍龃笙仍龃蠛蠼档?出現峰值;作為導軌系統重要設計參數,可以通過調整初始?jí)毫Ρ葋?lái)適應負載因素的變化,以達到更好的系統性能。
[Abstract]:The influence of load factors on the performance of hydrostatic guideway system is studied from the overall point of view. By using the theory of liquid resistance network and considering the viscosity-temperature effect of oil comprehensively, the mathematical relationship between the correlation parameters and the load factors is deduced, and the CFD calculation model based on the correlation parameters is established. Under different load conditions, according to the perturbation theory, fluent dynamic grid technique is used to solve the performance parameters of the guideway system, and then the vibration performance of the guideway system under pulse load is studied. The results show that the load factor and the initial pressure ratio have an effect on the performance parameters of the guideway system. When the load ratio is larger, the flow rate, the natural frequency and the maximum amplitude of the system will be smaller, and the damping to damping ratio will be larger. As an important design parameter of guideway system, the initial pressure ratio can be adjusted to adapt to the change of load factors in order to achieve better system performance.
【作者單位】： 中南大學機電工程學院;
【基金】：國家自然科學基金資助項目(51175518)~~
【分類號】：TH136

【相似文獻】

相關期刊論文 前2條

1 Ralf Moseberg;;減少振動[J];現代制造;2008年10期

2 高殿榮;張作超;趙建華;;基于PM流量控制器的開式液體靜壓導軌動態特性分析(英文)[J];機床與液壓;2012年06期

相關會議論文 前1條

1 鄭小龍;葉紅玲;沈靜嫻;;液體靜壓導軌轉臺的動力學建模[A];北京力學會第17屆學術年會論文集[C];2011年

，

本文編號：2438361