發布時間：2018-07-09 14:18

  本文選題：變速器 + 傳動效率�。� 參考：《機械傳動》2017年07期

【摘要】：變速器作為傳動系關鍵的零部件之一,直接影響整車的NEDC油耗。為了提升某MPV車型的NEDC綜合油耗,提出了一種基于NEDC工況的變速器效率測試方法,并利用該方法對比了不同潤滑油的黏度、溫度、添加劑等因素對變速箱傳動效率的影響。試驗表明,該測試方法能更準確地反映變速器NEDC工況下的綜合效率;潤滑油黏度相對越低,變速器的傳動效率越高;油溫升高引起的油膜厚度的減少對變速器效率的影響大于因轉速升高引起的油膜厚度的增加對變速器效率的影響,且有利于提高變速器的傳動效率;潤滑油增黏劑有利于提升油品的黏溫特性,且在一定溫度范圍內,隨著溫度的升高,潤滑油黏溫特性對于變速器傳動效率的影響大于潤滑油黏度對變速器傳動效率的影響。
[Abstract]:As one of the key parts of transmission system, transmission has a direct effect on NEDC fuel consumption. In order to improve the NEDC comprehensive fuel consumption of a certain MPV vehicle, a transmission efficiency test method based on NEDC operating condition is proposed, and the effects of different lubricating oil viscosity, temperature and additives on the transmission efficiency of the gearbox are compared by using this method. The test results show that the test method can more accurately reflect the overall efficiency of the transmission under NEDC conditions, and the lower the viscosity of lubricating oil, the higher the transmission efficiency. The decrease of oil film thickness caused by the increase of oil temperature has more influence on the transmission efficiency than that on the transmission efficiency caused by the increase of the oil film thickness, and it is beneficial to the transmission efficiency. The viscosity and temperature property of lubricating oil is more important to the transmission efficiency than the lubricating oil viscosity to the transmission efficiency in a certain temperature range.
【作者單位】： 武漢理工大學機電工程學院;上汽通用五菱汽車股份有限公司;
【基金】：校企合作基金項目(611605961)
【分類號】：TH132.46

【參考文獻】

相關期刊論文 前7條

1 劉傳波;董拓;莫易敏;周文駿;王俊平;;潤滑油黏度對后橋傳動效率和整車油耗影響的試驗研究[J];機械傳動;2015年05期

2 王治平;章新;;汽車變速器傳動效率的建模與仿真[J];汽車工程;2014年10期

3 莫易敏;常m鎦，

本文編號：2109633