本文關鍵詞： 高強自密實混凝土 配合比設計 工作性 強度 施工工藝　出處：《燕山大學》2014年碩士論文　論文類型：學位論文

【摘要】：深圳京基金融中心廣場是市重點工程，作為京基金融中心廣場核心的蔡屋圍金融中心更是將高達439米，為確保其施工進度及質量，本工程在塔樓核心筒及外框柱使用了高強自密實混凝土，，施工順序依次為-5層至46層使用C80自密實混凝土，47層至61層使用C70自密實混凝土，62層至73層使用了C60自密實混凝土。 秉承因地制宜，就地取材的原則，對配制高強自密實混凝土的原材料進行了優選。并在此基礎上，針對其低離析性和大流動性的技術難點，本工程采用了三摻粉煤灰、礦粉和聚羧酸外加劑的技術措施來進行高強自密實混凝土的配制。首先，對高強自密實混凝土的配合比進行了理論計算，得出了C60、C70、C80自密實混凝土的理論配合比；然后，經過實驗室實驗分析，研究了所配制混凝土的流動性、抗離析性、填充性等，在滿足初始配制要求的情況下，最終成功配制出C60、C80自密實混凝土，確定了其最優配比。同時還研究了原材料的變動對高強自密實混凝土性能的影響，為施工中的原材料稱量精度提供可靠的依據。 根據以上確定的配比，在施工現場成功配制出高強自密實混凝土，并將其成功泵送，應用于深圳京基金融中心廣場，經過嚴格的施工養護措施，獲得了令人滿意的施工質量，其經濟、社會效益顯著。
[Abstract]:Shenzhen Jingji Financial Center Square is a key project in the city. As the core of Jingji Financial Center Square, Cai Wuwei Financial Center will be as high as 439 meters. In order to ensure its construction progress and quality, In this project, high-strength self-compacting concrete is used in the core tube and outer frame column of the tower. The sequence of construction is -5 to 46 layers, C80 self-compacting concrete is used in 47 to 61 stories, C70 self-compacting concrete is used in 62 to 73 storeys, and C60 self-compacting concrete is used in the construction sequence. According to the principle of adapting measures to local conditions and selecting materials locally, the raw materials for the preparation of high strength self-compacting concrete have been selected. On this basis, in view of the technical difficulties of low segregation and high fluidity, the project has adopted three kinds of fly ash. The technical measures of mineral powder and polycarboxylic acid admixture are used to prepare high-strength self-compacting concrete. Firstly, the theoretical mix ratio of high-strength self-compacting concrete is calculated, and the theoretical mix ratio of C60C _ (70) C _ (70) C _ (80) self-compacting concrete is obtained. Through laboratory experiments and analysis, the fluidity, segregation resistance and filling property of concrete were studied. Finally, C60 C80 self-compacting concrete was prepared successfully under the condition that the initial preparation requirement was met. At the same time, the influence of the change of raw materials on the performance of high strength self-compacting concrete is studied, which provides a reliable basis for the weighing accuracy of raw materials in construction. According to the ratio determined above, the high strength self-compacting concrete is successfully prepared in the construction site, and successfully pumped, and applied to Shenzhen Jingji Financial Center Square. After strict construction maintenance measures, satisfactory construction quality is obtained. Its economy, social benefit is remarkable.
【學位授予單位】：燕山大學
【學位級別】：碩士
【學位授予年份】：2014
【分類號】：TU528;TU755

【參考文獻】

相關期刊論文 前10條

1 唐偉;高強自密實混凝土的試驗研究[J];四川建筑科學研究;2005年02期

2 劉小潔;余志武;;自密實混凝土的研究與應用綜述[J];鐵道科學與工程學報;2006年02期

3 張秋生;;自密實混凝土綜述[J];福建建筑;2009年05期

4 聶強;陳磊;牛文閣;;不同摻和料對水泥水化熱的影響[J];粉煤灰;2007年03期

5 翁友法,呂家良;自密實混凝土的研究現狀及其發展方向[J];中國港灣建設;2002年02期

6 趙筠;自密實混凝土的研究和應用[J];混凝土;2003年06期

7 齊永順;楊玉紅;;自密實混凝土的研究現狀分析及展望[J];混凝土;2007年01期

8 李志明,逄魯峰,袁惠星,崔安遠;免振搗混凝土的質量控制要點及工作性測試方法[J];混凝土與水泥制品;1998年06期

9 趙慶新;孫偉;楊正輝;楊健民;;自密實混凝土生產投料控制精度研究[J];建筑技術;2006年01期

10 繆漢良;杜艷靜;朱國平;葉燕華;;外加劑及礦物細摻料對自密實混凝土耐久性的影響[J];建筑技術;2009年01期

本文編號：1494095