本文選題：金屬材料 + 微米銀粉�。� 參考：《貴金屬》2017年02期

【摘要】：研究了以抗壞血酸為還原劑的液相還原法制備球形微米銀粉時的主要因素對振實密度和形貌的影響。實驗表明,酸性條件下制備的微米銀粉分散性較好。正交實驗表明,對銀粉振實密度的影響大小的因素依次為底液pH、硝酸銀濃度、分散劑PVP用量和實驗溫度。經過對銀粉進行粒度、SEM和XRD等測定表征發現,優化條件下可制備得到振實密度為4.2 g/cm~3,平均粒徑2.5μm,分散性良好的類球形銀粉。
[Abstract]:The effect of main factors on the density and morphology of spherical micron silver powder prepared by liquid phase reduction with ascorbic acid as reducing agent was studied.The experimental results show that the micron silver powder prepared under acidic conditions has good dispersion.The orthogonal experiment showed that the factors influencing the density of silver powder were pH of substrate, concentration of silver nitrate, amount of dispersant PVP and experimental temperature.The particle size of silver powder was measured by SEM and XRD. It was found that the spherical silver powder with a vibrational density of 4.2 g / cm ~ (3), average particle size of 2.5 渭 m and good dispersion could be prepared under the optimized conditions.
【作者單位】： 東北大學材料學院;西北有色金屬研究院;
【分類號】：TB383.3;TG146.32

【相似文獻】

相關期刊論文 前10條

1 李明利;余瓊;周宇松;錢坤明;周春江;杜丕一;;粒徑可控高振實密度球銀的制備工藝研究[J];稀有金屬材料與工程;2011年08期

2 郭志紅;李R，

本文編號：1744389