本文選題：波形板分離器 + 二次攜帶�。� 參考：《原子能科學技術》2016年05期

【摘要】：通過理論分析與三維數值模擬研究了實際運行工況下單鉤波形板分離器內二次攜帶機理。采用Realizable k-ε湍流模型對波形板內氣相流場進行數值模擬,利用離散相模型結合渦交互模型對水滴運動進行計算,根據壁面水膜運動方程求解水膜的速度與厚度分布;依據理論分析,對可能形成二次水滴的4種方式進行判定。結果表明:波形板內發生氣體動力造成的水滴破碎與水滴撞擊水膜產生飛濺的可能性較低,但較冷態工況的可能性高;水膜主要集中在波形板的前兩級,隨入口蒸汽速度或濕度的增加,水膜增厚并向下游移動;將水膜剝落和水膜分離的判別式進行統一,并證實波形板二次攜帶主要由水膜的剝落和分離造成,且相較水膜剝落,鉤峰處的水膜分離更易發生。
[Abstract]:Through theoretical analysis and 3D numerical simulation, the mechanism of secondary carrying in the order hook waveform plate separator is studied. The Realizable k- 蔚 turbulence model is used to simulate the gas phase flow field in the wavy plate, the discrete phase model and the vortex interaction model are used to calculate the water droplet motion, and the velocity and thickness distribution of the water film is calculated according to the motion equation of the water film on the wall. On the basis of theoretical analysis, four ways of forming secondary water droplets are determined. The results show that the possibility of water droplet breakup and water droplet impingement on water film is lower, but higher than that of cold condition, and the water film is mainly concentrated in the first two stages of the wave plate. With the increase of inlet steam velocity or humidity, the water film thickened and moved downstream, the discriminant of water film flaking and water film separation was unified, and it was proved that the second carrying of the wavy plate was mainly caused by the spalling and separation of the water film, and the flaking of the water film was more than that of the water film. Water membrane separation at the hook peak is more likely to occur.
【作者單位】： 核動力運行研究所;中核武漢核電運行技術股份有限公司;
【分類號】：O35

【參考文獻】

相關期刊論文 前4條

1 劉曉一;田瑞峰;陳軍亮;孫蘭昕;閻昌琪;;波形板壁液膜破裂實驗研究[J];核動力工程;2014年05期

2 臧麗葉;田瑞峰;孫蘭昕;邢治輝;田進云;;橫掠氣流作用下波形板壁降膜破裂分析[J];化工學報;2014年03期

3 丁凱;王進卿;池作和;張光學;孫公鋼;林貞宇;胡琳t，

本文編號：1801069