本文選題：充填材料配比　切入點：正交實驗法　出處：《煤礦安全》2017年12期 　論文類型：期刊論文

【摘要】：降低生產成本并滿足現場工程要求是選擇充填材料配比要考慮的2個主要指標。采用正交實驗設計方法確定實驗方案為三因素五水平,三因素為水泥含量百分比、灰矸比和膏體濃度。對實驗結果進行直觀分析和方差分析,得出影響早期強度的因素是水泥量百分比和膏體濃度,影響最終強度的因素是水泥量百分比和灰矸比。應用多元線性回歸和高斯消去法求解出膏體濃度的最優配比:水泥量百分比為12.705%,灰矸比為0.400,膏體濃度為77.498%。最后對最優配比的強度進行實驗室測試,第7 d的測試結果為0.93 MPa,第28 d的測試結果為3.21MPa,都滿足現場工程要求。
[Abstract]:Reducing the production cost and meeting the requirements of field engineering are the two main indexes to be considered in selecting the proportion of filling materials. The orthogonal experimental design method is used to determine that the experimental scheme is three factors and five levels, and three factors are the percentage of cement content. The direct analysis and variance analysis of the experimental results show that the factors affecting the early strength are the percentage of cement and the concentration of paste. The factors that affect the final strength are the percentage of cement content and the ratio of ash to gangue. The optimum proportion of paste concentration is obtained by using multiple linear regression and Gao Si elimination method: the percentage of cement content is 12.705%, the ratio of cement to gangue is 0.400, and the concentration of paste is 77.4988.Finally, the ratio of cement to gangue is 0.400, the ratio of cement to gangue is 0.400. The strength of the optimal ratio is tested in the laboratory, On the 7th day, the test results were 0.93 MPA, and on the 28th day the results were 3.21 MPA, which met the requirements of field engineering.
【作者單位】： 華北科技學院;遼寧工程技術大學礦業學院;
【基金】：國家自然科學基金資助項目(51174109,51074086) 中央高�；究蒲袠I(yè)務費資助項目(3142017095)
【分類號】：TD823.7

【相似文獻】

相關期刊論文 前10條

1 王正輝,靳學奇;物料粒度分布對泵送充填膏體性能的影響[J];有色礦山;2000年03期

2 方理剛;膏體泵送特性及減阻試驗[J];中國有色金屬學報;2001年04期

3 周華強,侯朝炯,孫�？�,瞿群迪,陳德俊;固體廢物膏體充填不遷村采煤[J];中國礦業大學學報;2004年02期

4 趙才智,周華強,瞿群迪,關明亮;膏體充填材料力學性能的初步實驗[J];中國礦業大學學報;2004年02期

5 趙才智;周華強;柏建彪;強輝;;膏體充填材料強度影響因素分析[J];遼寧工程技術大學學報;2006年06期

6 孫e，

本文編號：1641698