本文關鍵詞： 采煤機 無線監測裝置 壓電自供電 懸臂梁 壓電發電　出處：《傳感技術學報》2017年06期 　論文類型：期刊論文

【摘要】：考慮到壓電自供電裝置中壓電振子的幾何參數直接影響其共振頻率,從而影響壓電自供電裝置的發電量,因此需要根據環境激勵頻率設定最佳的壓電振子的幾何參數,對基于壓電自供電的采煤機狀態無線監測裝置進行研究,通過理論分析、仿真以及實驗方法對對不同懸臂梁結構在不同外界激勵作用下的發電量進行研究。研究結果表明:懸臂梁自由端的質量塊質量以及懸臂梁長度越大,懸臂梁壓電結構的固有頻率越低;隨著懸臂梁厚度的增加,懸臂梁壓電結構的固有頻率逐漸增大。以此為依據對采煤機不同監測位置的裝置選取最佳匹配的壓電結構幾何參數,并通過采煤機工作狀態監測實驗驗證了本文研究的壓電自供電無線監測裝置的可行性。
[Abstract]:Considering that the geometric parameters of piezoelectric oscillators directly affect the resonance frequency of piezoelectric self-supply devices, and thus affect the generation of electricity of piezoelectric self-supply devices, it is necessary to set the optimum geometric parameters of piezoelectric oscillators according to the ambient excitation frequency, The wireless monitoring device of shearer state based on piezoelectric self-power supply is studied, and the theoretical analysis is carried out. The power generation of different cantilever beam structures under different external excitations is studied by simulation and experimental methods. The results show that the mass mass and the length of cantilever beam at the free end of cantilever beam increase. The lower the natural frequency of cantilever piezoelectric structure is, the more the natural frequency of cantilever piezoelectric structure increases with the increase of cantilever beam thickness. The feasibility of the piezoelectric self-supply wireless monitoring device studied in this paper is verified by the working state monitoring experiment of the shearer.
【作者單位】： 遼寧工程技術大學機械工程學院;
【基金】：遼寧省教育廳創新團隊項目(LTJ2011101,LT20100047)
【分類號】：TD632.1

【相似文獻】

相關期刊論文 前1條

1 晨春翔;劉春明;;礦山安全無線監測動態分析系統的研制[J];煤礦機電;2008年02期

相關碩士學位論文 前1條

1 陳寶強;采空區環境無線監測系統研究開發[D];中國礦業大學;2016年

，

本文編號：1533162