【摘要】：針對城鎮污水廠污泥固化處理周期長、效能低的問題,研發城鎮污水廠污泥快速(3d)固化劑�？疾炝肆蜾X酸鹽水泥、硅酸鹽水泥、高錳酸鉀、早強減水劑、粉煤灰、石灰等多種固化材料和添加劑對固化體強度的影響。結果表明,隨著硫鋁酸鹽水泥、硅酸鹽水泥、高錳酸鉀、早強減水劑和粉煤灰摻入量的增加,3 d固化體抗壓強度逐步提高,其影響順序?yàn)?硫鋁酸鹽水泥硅酸鹽水泥高錳酸鉀早強減水劑粉煤灰;石灰對固化體強度影響顯著;膨潤土和石膏對增強固化體強度作用較小。快速固化劑組分及其配比為硫鋁酸鹽水泥(3.9%)、硅酸鹽水泥(3%)、石灰(1.7%)、粉煤灰(6%),其3 d固化強度滿足污泥填埋處置的要求。固化體浸出液中COD、氨氮濃度顯著降低;SEM結果表明,固化污泥顆粒較脫水污泥具有孔隙率小、結構密實、含有大量顆粒狀結晶的特點。
[Abstract]:In order to solve the problem of long solidification period and low efficiency of sludge solidification in urban wastewater treatment plant, a rapid (3 d) solidifying agent was developed. The effects of sulphoaluminate cement, Portland cement, potassium permanganate, early strength water reducer, fly ash, lime and other curing materials and additives on the strength of solidified body were investigated. The results show that the compressive strength of the solidified body increases gradually with the increase of the content of sulphoaluminate cement, Portland cement, potassium permanganate, early strength water reducer and fly ash. The order of influence is as follows: sulfite cement Portland cement potassium permanganate early strength reducer fly ash lime has a significant effect on the strength of solidified body bentonite and gypsum have little effect on strengthening the strength of solidified body. The rapid curing agent composition and its proportion are sulphoaluminate cement (3.9%), Portland cement (3%), lime (1.7%) and fly ash (6%). The SEM results showed that the solidified sludge particles had smaller porosity, denser structure and a large number of granular crystals than those of dewatered sludge.
【作者單位】： 重慶大學三峽庫區生態環境教育部重點實驗室;
【基金】：國家水體污染控制與治理科技重大專項(2012ZX07307-002)
【分類號】：X703

【相似文獻】

相關期刊論文 前10條

1 張華,羅上庚,姜耀中,周慧;低氧條件下浸出劑和溫度對固化體浸出行為的影響[J];核化學與放射化學;2005年03期

2 吳萍萍;張騁;徐海芳;黃德新;徐冰;蔣丹宇;;玻璃固化體抗浸蝕性能實驗研究進展[J];現代技術陶瓷;2010年03期

3 馬輝;陳泉水;梁磐儀;郁興國;劉曉東;任廣元;;摻雜釹的磷酸鈰獨居石固化體合成研究[J];陶瓷學報;2012年01期

4 盛嘉偉，，羅上庚，湯寶龍;模擬高放玻璃固化體浸出行為的研究Ⅰ．溫度對固化體浸出的影響[J];核化學與放射化學;1996年04期

5 金立云;李云;高月英;孫秀峰;高宏;;模擬玻璃固化體中26個主、次及微量元素的X射線熒光光譜法測定[J];中國原子能科學研究院年報;1992年00期

6 趙顏紅;潘社奇;李長成;張洪滔;;放射性焚燒灰堿激發膠凝材料固化體浸出實驗[J];核化學與放射化學;2010年05期

7 毛仙鶴;袁曉寧;秦志桂;陳e

本文編號：2190110