【摘要】：對實驗用板式精餾塔醇-水體系的實際操作效果與Aspen Plus軟件模擬結果進行了對比分析,既從理論上推算實驗用板式精餾塔的應用潛力,也實現了用實驗數據對化工模擬軟件的實際驗證。首先在實驗室中用內徑68 mm、塔板數為10的篩板精餾塔對一定濃度的酒精溶液進行了連續精餾,獲得了相關數據;然后用Aspen Plus軟件對相同的體系進行了模擬計算,并把實測數據和模擬結果進行了對比分析。結果表明:實驗測得的進出塔組成與Aspen Plus軟件計算的組成有差別,但偏差處于合理范圍之內。精餾段和提餾段的操作線、選用的實際回流比、實際的進料板位置與Aspen Plus軟件計算結果比較符合。實驗數據進一步驗證了用Aspen Plus軟件進行設計計算符合實際,結果可用。
[Abstract]:The actual operating effect of the alcohol-water system of plate distillation column used in the experiment is compared with the simulation results of Aspen Plus software, and the application potential of the plate distillation column used in the experiment is calculated theoretically. It also realizes the actual verification of chemical engineering simulation software with the experimental data. Firstly, a sieve-plate distillation column with the inner diameter of 68 mm, with 10 trays was used for continuous distillation of alcohol solution with a certain concentration in the laboratory, and the related data were obtained. Then the Aspen Plus software is used to simulate the same system, and the measured data and simulation results are compared and analyzed. The results show that the composition of the tower measured by the experiment is different from that calculated by Aspen Plus software, but the deviation is within a reasonable range. The actual reflux ratio and the position of feed plate are in good agreement with the calculation results of Aspen Plus software for the operating line of the distillation section and the distillation section. The experimental data further verify that the design calculation with Aspen Plus software accords with the reality and the results can be used.
【作者單位】： 山東師范大學化學化工與材料科學學院;
【基金】：山東省自然科學基金項目(ZR2013EMM004) 國家級大學生創新創業訓練計劃項目(201610445058)
【分類號】：TP391.9;TQ053.5

【相似文獻】

相關期刊論文 前10條

1 何一夫;;基于Aspen Plus軟件的超大規�？辗止に嚾鞒棠M[J];上海化工;2013年11期

2 趙月紅,溫浩,許志宏;Aspen Plus用戶模型開發方法探討[J];計算機與應用化學;2003年04期

3 衛林;陳巍巍;;Aspen Plus在精餾塔工藝設計中的應用[J];科技致富向?qū)?2013年15期

4 朱登磊;譚超;任根寬;;基于Aspen plus萃取精餾的概念設計及優化[J];計算機與應用化學;2010年06期

5 何光洪;邱方利;林可洪;張穎心;宋賢民;;Aspen Plus在化工設計物料衡算中的應用[J];化工時刊;2012年07期

6 薛笠;潘哲;郝大雪;;基于Aspen Plus的氨吸收制冷流程模擬[J];山東化工;2013年04期

7 樊艷良;;用Aspen Plus對反應精餾的模擬計算[J];上�；�;2007年05期

8 王帥;鐘宏;金一粟;滿瑞林;李海普;;Aspen Plus在化工專業教學中的應用[J];化工時刊;2010年02期

9 盧澤湘;范立維;廖益強;;Aspen Plus在《分離工程》教學中的應用[J];福建農林大學學報(哲學社會科學版);2010年05期

10 姜薇;馬瑞;趙峰;張桂林;;天然氣水蒸汽轉化制氫的Aspen plus模擬分析[J];天然氣化工(C1化學與化工);2013年01期

相關碩士學位論文 前1條

1 王新成;基于Aspen Plus的超重力精餾過程模擬與優化[D];中北大學;2014年

，

本文編號：2446119