長槳短葉片復合攪拌槳混合性能研究
發布時間:2018-03-06 02:26
本文選題:復合攪拌槳 切入點:中高粘度 出處:《東南大學》2015年碩士論文 論文類型:學位論文
【摘要】:針對長槳短葉片復合攪拌槳(LSB),從功率消耗、混合時間和流型三個角度,研究了其在流體混合過程的性能特性。首先對攪拌槳在釜內的功率消耗進行了測量,考察攪拌槳的結構參數、攪拌槳的安裝高度、擋板的安裝距離和操作條件等對功率消耗的影響。研究發現,在相同轉速下,隨著液面高度的增大,單位體積功率消耗相應的增大;在相同液面高度下,隨著轉速的增大,單位體積功率消耗呈指數增大。固定長槳:長槳LB-1,外環β=0°,當H/T1.4,在不同轉速下短葉片對于單位體積功率消耗的影響滿足以下關系:CSBSB-2SB-1;當H/T≥1.4,短葉片對于單位體積功率消耗的影響大小為:CSB≥SB-2≥SB-1,在液面高度H/T≥1.4時,SB-1具有良好的混合性能。固定攪拌槳安裝高度,對于攪拌槳(LB-1,β=0°,SB-1),當ΔC=0.05時,Np最;固定擋板安裝距離,隨著C/T增大,Np減小。為了研究LSB攪拌槳的混合效率,采用平面激光誘導熒光技術(PLIF)對流體在釜內混合時間進行測量,將復合槳(LB-1,β=0°,SB-1)與標準雙層渦輪槳DT進行對比:針對LSB攪拌槳考察了攪拌槳的轉速(N)、液面高度(H)、擋板的安裝距離(ΔC)對混合時間的影響。實驗結果表明,LSB適用于長徑比較大的混合設備,且相對于雙層渦輪槳具體優越的混合性能,特別適用于中高粘度流體的混合,在低轉速下能以較低的功率消耗提供更好地混合效果;針對LSB攪拌槳實驗發現,在液面高度較低時(H=T),擋板的安裝距離(ΔC)對混合時間沒有明顯的影響,然而隨著液面高度的增加擋板距離壁面的距離(ΔC)對混合時間的影響明顯增大;在相同液面高度下,增大擋板與壁面的距離混合時間降低。針對在LSB攪拌槳的作用下,釜內流體的流動形態,實驗主要從長槳的形狀、攪拌槽的結構以及液面高度幾個方面進行了討論。結果表明擋板距離壁面一定的距離(ΔC=0.025T)有利于高粘度流體的混合,當距離過大時(ΔC/T=0.1)會阻礙流體之間的混合。在H=T時新型攪拌槳在槽內形成典型的軸流式流型,隨著液面高度的增加,長槳對液體的剪切作用越強,流體在長徑比較大的攪拌槽內形成軸徑向混合流,長槳過寬時(LB-4),長槳的剪切力大于短葉片的作用,主流體在槽內做切向運動;在H=1.5T時,當C/T≈0.33-0.5槽內流體具有良好的混合效果。本文利用實驗證實了新型復合式攪拌槳,能有效適用于H/T1.0的條件。確定了較優的攪拌槳形狀參數:長槳,LB-2,β=0°;短葉片,SB-1;以及相應的攪拌釜的形狀參數:△C/T=0.05; CIT,0.33-0.5。
[Abstract]:In this paper, the performance characteristics of the long and short blade composite agitator in the fluid mixing process are studied from three aspects: power consumption, mixing time and flow pattern. First, the power consumption of the impeller in the kettle is measured. The effects of the structural parameters of the impeller, the installation height of the impeller, the installation distance of the baffle and the operating conditions on the power consumption are investigated. It is found that at the same rotational speed, with the increase of the height of the liquid level, The unit volume power consumption increases accordingly; at the same liquid level height, with the increase of rotational speed, Unit volume power consumption increased exponentially. Fixed long propeller: long propeller LB-1, outer ring 尾 = 0 擄, when H / T 1.4, the influence of short blade on unit volume power consumption at different rotational speeds satisfies the following relation: CSBSB-2SB-1; when H / T 鈮,
本文編號:1572947
本文鏈接:http://sikaile.net/kejilunwen/huagong/1572947.html
最近更新
教材專著