發布時間：2018-12-06 12:18

【摘要】：采用基于轉子多頻橢圓渦動模型和動網格技術的URANS方程求解方法,研究了動、靜葉干涉作用以及級間補汽導致的非均勻進汽溫度和壓力條件下葉頂迷宮密封汽流激振轉子動力特性,計算分析了進汽預旋比為0.2、0.5、0.7時葉頂迷宮密封轉子動力特性系數,并與均勻進汽溫度和壓力條件下迷宮密封轉子動力特性系數進行了比較。研究結果表明:密封轉子穩定性隨進汽預旋比的增加而降低;非均勻和均勻進汽條件下迷宮密封腔室周向旋流強度和腔室壓力分布的差異隨進汽預旋比的增加而逐漸減小,2種進汽條件下密封轉子動力特性系數之間的差異隨進汽預旋比的增加而減小;與均勻進汽相比,進汽預旋比為0.2時非均勻進汽下迷宮密封交叉剛度至少降低82.7%,交叉阻尼至少增加30.7%;進汽預旋比為0.5時非均勻進汽下迷宮密封有效阻尼僅在渦動頻率為50~100 Hz時較均勻進汽低8.4%~12.4%;進汽預旋比增加至0.7時,非均勻和均勻進汽條件下迷宮密封轉子動力特性系數基本相同。顯然,進汽預旋比較高時進汽均勻性對迷宮密封汽流激振轉子動力特性系數的影響可以忽略。
[Abstract]:Based on the rotor multi-frequency elliptical vortex model and the moving grid technique, the URANS equation solution method is used to study the motion. The dynamic characteristics of a labyrinth sealed rotor with steam excitation caused by static blade interference and non-uniform inlet temperature and pressure caused by interstage steam supply are analyzed. The dynamic characteristic coefficients of the labyrinth seal rotor are calculated and analyzed when the prespin ratio of inlet steam is 0.2g 0.50.0.The coefficient is compared with that of the labyrinth seal rotor under uniform inlet temperature and pressure. The results show that the stability of the sealed rotor decreases with the increase of the prespin ratio of inlet steam. The difference between circumferential swirl intensity and chamber pressure distribution of labyrinth seal chamber decreases with the increase of intake prespin ratio. The difference between the dynamic characteristic coefficients of the seal rotor decreases with the increase of the intake prespin ratio under the two kinds of steam inlet conditions. Compared with uniform steam intake, the cross stiffness of labyrinth seal under non-uniform inlet steam is reduced by 82.7%, and the cross damping is increased by 30.7%. The effective damping of the labyrinth seal under the non-uniform inlet steam is only 8.4% 12.4 lower than that of the uniform inlet when the vortex frequency is 50 ~ 100 Hz. The dynamic coefficients of the labyrinth seal rotor are basically the same when the prespin ratio of inlet steam is increased to 0.7. It is obvious that the influence of the uniformity of inlet steam on the dynamic coefficients of labyrinth seal steam flow excited rotor can be neglected when the intake prerotation is high.
【作者單位】： 西安交通大學能源與動力工程學院;先進航空發動機協同創新中心;
【基金】：國家自然科學基金資助項目(51376144)
【分類號】：TH136

【相似文獻】

相關期刊論文 前1條

1 汪劍波;;燃?xì)鈾C(jī)組低壓主蒸汽進汽控制閥卡澀故障分析及處理[J];中國設備工程;2014年03期

相關會議論文 前1條

1 徐嗣華;華文祥;王宇翔;劉麗平;冀大偉;;兩次再熱機組進汽閥門的開發[A];中國動力工程學會透平專業委員會2013年學術研討會——S01汽輪機論文集[C];2013年

，

本文編號：2366014