本文選題：Halbach排列 + 擺線永磁齒輪�。� 參考：《機械強度》2017年01期

【摘要】：擺線永磁齒輪是通過內轉子本身自轉和公轉來傳遞轉速,可以獲得較高的傳動比和轉矩密度。為改善漏磁、提高永磁體利用率,將永磁體采用Halbach排列,根據其工作原理設計制造了一臺樣機。通過有限元模擬擺線永磁齒輪的磁場分布和靜態轉矩特性。與一般結構相比,采用90°Halbach結構時最大轉矩密度的平均值可提高30%左右,且最大轉矩密度的波動較小,傳動更平穩。最后,通過實驗分別測試轉子不同轉角時的傳動轉矩,所得結果與模擬結果比較吻合。結果表明基于Halbach排列的擺線永磁齒輪可以有效的改善漏磁現象,獲得更高的轉矩密度。
[Abstract]:The cycloidal permanent magnet gear transfers the rotational speed through the rotation and rotation of the inner rotor itself, which can obtain higher transmission ratio and torque density. In order to improve magnetic flux leakage and improve the utilization ratio of permanent magnets, a prototype was designed and manufactured according to the working principle of the permanent magnets arranged by Halbach. The magnetic field distribution and static torque characteristics of cycloid permanent magnet gear were simulated by finite element method. Compared with the general structure, the average maximum torque density of 90 擄Halbach structure can be increased by about 30%, and the fluctuation of the maximum torque density is smaller and the transmission is more stable. Finally, the torque of the rotor with different rotation angles is measured by experiments, and the results are in good agreement with the simulation results. The results show that cycloidal permanent magnetic gears based on Halbach arrangement can effectively improve magnetic flux leakage and obtain higher torque density.
【作者單位】： 浙江工業大學;新譽集團;
【分類號】：TH132.41

【參考文獻】

相關期刊論文 前4條

1 高竹發;郝偉娜;周全;;Halbach陣列型擺線永磁齒輪渦流損耗的有限元計算[J];機械強度;2014年05期

2 葛研軍;聶重陽;辛強;;調制式永磁齒輪氣隙磁場及轉矩分析計算[J];機械工程學報;2012年11期

3 朱學軍;許立忠;;永磁行星齒輪傳動的參數設計與轉矩分析[J];中國機械工程;2010年05期

4 田杰;鄧輝華;趙韓;王勇;;稀土永磁齒輪傳動系統動態仿真研究[J];中國機械工程;2006年22期

【共引文獻】

相關期刊論文 前10條

1 郝偉娜;周俊;;基于Halbach排列的擺線永磁齒輪[J];機械強度;2017年01期

2 付興賀;王標;林明耀;;磁力齒輪發展綜述[J];電工技術學報;2016年18期

3 葛研軍;袁直;賈峰;楊均悅;周凱凱;;籠型異步磁力耦合器機械特性與試驗[J];農業工程學報;2016年12期

4 葛研軍;胡浩;王s，

本文編號：1802238