【摘要】：采用粘土、鋁礬土、碳酸鈣為主要原料制備以貝利特(C_2S)、硫鋁酸鈣和鐵鋁酸鈣為主導礦物的低碳排放水泥熟料(BCSAF),并通過硼(B)和鈉(Na)復合摻雜對C_2S礦物進行活化。將熟料與無水石膏按比例混合后制備水泥,研究復合摻雜對水泥凈漿強度及微觀結構的影響。采用X射線衍射全譜擬合定量相分析法、紅外光譜、掃描電子顯微鏡、X射線能譜分析等測試方法表征熟料及水泥水化漿體組成與結構。研究結果表明,一定摻量的B和Na復合摻雜制備BCSAF水泥熟料可在常溫下穩定α′-C_2S或更高活性的C_2S,減少熟料中β-C_2S含量,從而實現C_2S礦物的活化,提高BCSAF水泥熟料早期水化活性,顯著提高水泥漿體抗壓強度。
[Abstract]:Using clay, bauxite and calcium carbonate as main raw materials, low carbon discharge cement clinker (BCSAF), was prepared with C _ 2S, Ca _ 2SO _ 4 and Ca _ 2SO _ 4 as dominant minerals. C _ 2S minerals were activated by boron (B) and sodium (Na) doping. Cement was prepared by mixing clinker and anhydrous gypsum in proportion to study the effect of composite doping on the strength and microstructure of cement paste. The composition and structure of clinker and cement hydrated slurry were characterized by X-ray diffraction full-spectrum fitting quantitative phase analysis, infrared spectrum and scanning electron microscope X-ray spectrum analysis. The results show that the preparation of BCSAF cement clinker with certain amount of B and Na can stabilize 偽 -C _ 2S or higher activity C _ 2s at room temperature, reduce 尾 -C2S content in clinker, thus realize the activation of C _ 2S minerals and improve the early hydration activity of BCSAF cement clinker. The compressive strength of cement paste is improved significantly.
【作者單位】： 同濟大學先進土木工程材料教育部重點實驗室;
【基金】：上海市國際科技合作基金(12230708700)
【分類號】：TQ172.1

【相似文獻】

相關期刊論文 前10條

1 張巨松,李好新,隋智通;氧化鈦對無水硫鋁酸鈣形成的熱分析實驗研究[J];沈陽建筑工程學院學報(自然科學版);2002年03期

2 張巨松,隋智通,回志峰,安會勇;鈣鈦礦對無水硫鋁酸鈣形成的影響[J];東北大學學報;2005年03期

3 趙改菊;謝峻林;路春美;韓奎華;;高溫固硫物相硫鋁酸鈣的生成過程研究[J];燃料化學學報;2006年06期

4 薛君s，

本文編號：2191816