【摘要】：空氣泡沫驅在延長油田取得了較好的開發效果,但是其對注入系統的腐蝕、對地層傷害一直是制約該技術應用的瓶頸問題。針對空氣泡沫驅注入系統的腐蝕機理、危害程度進行系統研究和評價,篩選出適合延長油田工況條件下的緩蝕劑,研究注入介質(泡沫、空氣、地表水)與地層配伍性、從而評價空氣泡沫驅對地層的傷害程度、并制定相應對策,是目前急需解決的關鍵問題。通過對注入系統腐蝕產物的分析可知腐蝕產物主要以氧化鐵為主,次之為CaCO3,FeS、SiO2、Al2O3含量則相對較少。腐蝕試驗說明:空氣壓力越高,腐蝕速率越快,這與腐蝕介質中氧分壓的增大有關。泡沫液與空氣交替注入次數越多,腐蝕速率越高,頻繁交替注入使得水與氧氣共存。溫度越高、氧擴散越快,腐蝕越快。注入空氣濕度越大,腐蝕速率越高。在注入系統的腐蝕防護方面,緩蝕劑CT2-17和犧牲陽極保護法可以較好的用于甘谷驛油田空氣泡沫驅。在對地層傷害方面,空氣與甘谷驛地層原油后會發生低溫氧化反應,產生大量的CO2,酸性的二氧化碳?xì)怏w會溶蝕多孔介質提高儲層的滲透率,當?shù)貙铀畃H改變時易產生CaCO3沉淀。更重要的是地層中容易出現細菌堵塞,因此在注空氣泡沫驅時需要加入殺菌劑。殺菌劑可有效降低腐蝕速率。起泡劑的腐蝕程度較輕,其中始創起泡劑C的性能最好,最適合甘谷驛油田的空氣泡沫驅。本文結果對甘谷驛油田空氣泡沫驅的腐蝕機理認識及采取有效的防護措施具有重要的指導意義。
[Abstract]:Air foam flooding has achieved good development effect in Yanchang Oilfield, but its corrosion to injection system and formation damage have been the bottleneck problems restricting the application of this technology. According to the corrosion mechanism and damage degree of air foam flooding injection system, the corrosion inhibitor suitable for prolonging the working conditions of oil field was screened out, and the compatibility of injected medium (foam, air, surface water) with formation was studied. Therefore, it is a key problem to be solved urgently to evaluate the damage degree of air foam flooding to formation and to formulate corresponding countermeasures. Through the analysis of the corrosion products of the injection system, it can be seen that the corrosion products are mainly iron oxide, followed by the content of CaCO3,FeS,SiO2,Al2O3 is relatively small. The corrosion test shows that the higher the air pressure, the faster the corrosion rate, which is related to the increase of oxygen partial pressure in corrosive medium. The higher the times of alternating injection of foam liquid and air, the higher the corrosion rate, and the higher the corrosion rate is, the more frequent alternate injection of water and oxygen makes the coexistence of water and oxygen. The higher the temperature, the faster oxygen diffusion and corrosion. The higher the air humidity, the higher the corrosion rate. In the aspect of corrosion protection of injection system, corrosion inhibitor CT2-17 and sacrificial anode protection can be used for air foam flooding in Ganguyi Oilfield. In terms of formation damage, air and Ganguyi formation crude oil will be oxidized at low temperature, and a large amount of CO2, acid carbon dioxide gas will dissolve the porous media to improve the permeability of the reservoir, and the formation water pH changes will easily produce CaCO3 precipitation. More importantly, bacterial clogging is easy to occur in the formation, so fungicides should be added to air foam flooding. Fungicides can effectively reduce the corrosion rate. The degree of corrosion of foaming agent is relatively light, among which the performance of foaming agent C is the best, which is the most suitable for air foam flooding in Ganguyi Oilfield. The results of this paper have important guiding significance for understanding the corrosion mechanism of air foam flooding and taking effective protective measures in Ganguyi Oilfield.
【學位授予單位】：西安石油大學
【學位級別】：碩士
【學位授予年份】：2015
【分類號】：TE357.46

【參考文獻】

相關期刊論文 前10條

1 孫偉峰;李顯斌;劉正杰;張偉;;空氣泡沫驅提高采收率技術在魏崗油田的應用[J];石油地質與工程;2011年03期

2 沈煥文;劉媛社;趙輝;王碧濤;莫磊;;五里灣長6油藏復合空氣泡沫驅試驗效果評價[J];石油化工應用;2011年03期

3 陳輝;;非均質油藏特高含水開發期空氣泡沫驅實驗研究[J];山東大學學報(工學版);2011年01期

4 劉雅馨;張用德;呂古賢;張扣宏;劉洪敏;;數值模擬在低滲裂縫油藏調剖中的研究應用[J];西南石油大學學報(自然科學版);2011年01期

5 高海濤;李雪峰;趙斌;張兵濤;鄧德亭;;中滲特高含水油藏空氣泡沫調驅先導試驗[J];油田化學;2010年04期

6 宋淵娟;許耀波;曹晶;許飛;蘇林;;低滲透油藏空氣泡沫復合驅油室內實驗研究[J];特種油氣藏;2009年05期

7 劉麗莉;聶仁峰;梁于文;鄭宇霞;陶紅;;空氣泡沫調驅提高采收率研究[J];斷塊油氣田;2009年04期

8 林偉民;史江恒;肖良;何隆英;任韶然;;中高滲油藏空氣泡沫調驅技術[J];石油鉆采工藝;2009年S1期

9 任韶然;于洪敏;左景欒;高海濤;林偉民;;中原油田空氣泡沫調驅提高采收率技術[J];石油學報;2009年03期

10 張力;董立全;張凱;董時正;;空氣-泡沫驅技術在馬嶺油田試驗研究[J];新疆地質;2009年01期

，

本文編號：2291044