發布時間：2018-05-26 17:04

  本文選題：垃圾填埋氣 + 重整�。� 參考：《化學工程》2017年02期

【摘要】：采用吉布斯自由能最小法對垃圾填埋氣(簡化為甲烷與二氧化碳混合物)部分氧化重整制合成氣進行了熱力學分析,得出了生成適于費托反應的合成氣組分的最適反應條件。結果顯示:當反應溫度大于1 073 K時,CH_4轉化率大于99%,反應生成的氣體中CH_4的含量小于0.25%。分別提高反應溫度和O_2/CH_4摩爾比均有助于抑制積炭的生成。反應生成的氣體中,H_2和CO分別達到最大值時,所對應的反應條件的范圍不同,但在特定條件下它們有所重疊。填埋氣組分CO_2/CH_4摩爾比分別為0.5,0.7,0.9時,通過等高線法得到了生成適于費托反應的合成氣組分所需的最適反應條件,而CO_2/CH_4摩爾比為1.1時,無法獲得相應的最適反應條件。
[Abstract]:The Gibbs free energy minimization method was used for thermodynamic analysis of partial oxidation reforming of landfill gas (simplified as mixture of methane and carbon dioxide) to produce syngas, and the optimum reaction conditions for the formation of syngas components suitable for Fischer reaction were obtained. The results show that when the reaction temperature is greater than 1 073 K, the conversion of CH4 is greater than 99 and the content of CH_4 in the gas produced by the reaction is less than 0.25. Increasing the reaction temperature and the molar ratio of O_2/CH_4 can inhibit the formation of carbon deposition. When the maximum values of H2 and CO in the gas produced by the reaction are different, the corresponding reaction conditions are different, but they overlap under certain conditions. When the CO_2/CH_4 molar ratio of landfill gas component is 0.5? 0. 7%, the optimum reaction conditions for the synthesis gas component suitable for Fischer reaction are obtained by contour method, but when the CO_2/CH_4 molar ratio is 1. 1, the corresponding optimum reaction conditions can not be obtained.
【作者單位】： 華南理工大學機械與汽車工程學院;
【基金】：廣州市科技計劃項目(2014J4100014)
【分類號】：X705;TE665.3

【參考文獻】

相關期刊論文 前1條

1 王紅民;孫炎軍;;垃圾填埋氣的資源化利用[J];當代化工;2015年01期

相關碩士學位論文 前1條

1 陳曉梅;城市生活垃圾衛生填埋場甲烷利用研究[D];暨南大學;2011年

【共引文獻】

相關期刊論文 前1條

1 王紅民;陳方;;垃圾填埋氣部分氧化重整制合成氣的熱力學分析[J];化學工程;2017年02期

相關碩士學位論文 前5條

1 張昊e，

本文編號：1938113