本文選題：固井 + 膠結強度��； 參考：《西南石油大學》2015年博士論文

【摘要】：固井界面膠結強度與水泥環層間封隔能力密切相關,而層間封隔能力則是一個關系到安全生產、資源開發效率、經濟效益和生態環境保護的綜合問題。研究提高或改善界面膠結質量是一項系統工程,需要研究鉆井、完井施工作業中不同工作液的性能以及相互作用時工作液的性能,不是研究某種單一的工作液就可以提高界面膠結質量。本文將鉆井液、前置液、水泥漿三種工作液作為整體、以縱向體系的方式研究影響界面膠結質量的因素。使用離子型共聚單體AMPS和NaSS制備出用于油井水泥的ASL無皂膠乳。ASL無皂膠乳具有良好的乳液穩定性、成膜性和熱穩定性。使用紅外光譜和透射電鏡研究方法分析了ASL無皂膠乳的化學組分和微觀形貌。與THD-818市售膠乳以及NSL傳統膠乳相比,ASL無皂膠乳在未加穩定劑時就具有良好的離子穩定性。研究發現AMPS/NaSS的用量在1.3%-1.9%時,ASL無皂膠乳水泥的抗壓強度和膠結強度較高。在ASL膠乳水泥漿中加入適量的消泡劑有利于提高膠乳水泥漿的密度和水泥石的抗壓強度,D50消泡劑適宜的用量為0.8%；ASL-13膠乳加量為10%-20%時,膠乳水泥漿具有良好的性能,水泥石具有較高的抗壓強度和膠結強度；ASL膠乳水泥漿在70℃C和90℃C時有良好的稠化曲線；隨著養護溫度(70-C～90℃C)的增高或養護時間(1天～15天)的增長,ASL膠乳水泥石的抗壓強度和膠結強度均有所增加。使用X衍射分析和綜合熱分析發現ASL-13膠乳水泥和空白水泥在水泥本體和界面膠結處的水化產物差別很大。在水泥本體中,ASL-13膠乳水泥含有膠乳和較多的碳酸鈣,而空白水泥樣品中含有較多的氫氧化鈣；在膠結界面處,ASL-13膠乳在界面處抑制了氫氧化鈣晶體的生長、增加了碳酸鈣或鈣礬石(AFt)含量、促進了凝膠類水化產物的生長,這些水化產物有利于提高界面膠結強度。使用掃描電鏡分析觀察到ASL-13膠乳水泥樣品和THD-815膠乳水泥樣品中都有膜類物質,而且ASL膠乳水泥石的表面粗糙度顯著降低。ASL無皂膠乳在油井水泥中的作用機理可以分為兩個方面：一是在水泥漿中,傳統膠乳依靠乳化劑與水泥顆粒之間的范德華力吸附在水泥顆粒表面。而ASL無皂膠乳是由膠乳粒子表面的離子基團與水泥顆粒形成離子鍵,同時膠乳粒子以離子鍵的形式吸附在晶體表面而形成空間位阻,改變了晶體的生長規則,破壞了晶體的正常增長,使得結晶類水化產物的體積減�。欢窃谒嗍�,在ASL膠乳膜和水泥界面之間是以離子鍵的形式黏合的,而傳統膠乳水泥中,膠乳膜和水泥界面之間是由乳化劑等物質填充的,因此無皂膠乳水泥表現出較高的抗壓強度和膠結強度。研究對多種鉆井液具有良好沖洗能力的雙相前置液體系,前置液在室溫及高溫稠化后具有良好熱穩定性、流變性和懸浮穩定性。前置液與鉆井液和水泥漿均有良好的相容性和穩定性。前置液與ASL膠乳水泥漿混合后,對水泥漿的稠化曲線無不良影響。同時使用雙相前置液和ASL膠乳水泥時,界面膠結強度最高。雙相前置液中的微硅、礦渣等活性材料參與界面處的水泥水化反應,消耗了界面處的氫氧化鈣,具有膨脹性的結晶類產物增多；同時使用雙相前置液和ASL膠乳水泥時,膠結界面處形成大量結晶類和凝膠類物質,提高了膠結質量。這些實驗結果說明ASL無皂膠乳水泥性能良好,與雙相前置液配合使用時,可以顯著地提高界面膠結強度,有利于提高水泥環的層間封隔能力,提高固井質量。
[Abstract]:Cementing strength is closely related to the interlayer sealing ability of cement ring, and interlayer sealing ability is a comprehensive problem related to safety production, resource development efficiency, economic benefit and ecological environment protection. It is a systematic process to study and improve the interface cementation quality. It is necessary to study drilling and different completion construction operations. The performance of the working fluid and the performance of the working fluid at the time of interaction are not to study a single working fluid to improve the bonding quality of the interface. In this paper, three working fluids of drilling fluid, preliquid and cement slurry are used as a whole to study the factors affecting the interfacial cementation in a vertical system. The use of ionic copolymerized monomers AMPS and NaSS ASL soap free latex.ASL emulsifier free latex used for oil well cement has good emulsion stability, film formation and thermal stability. The chemical composition and Micromorphology of ASL soap free latex are analyzed by infrared and transmission electron microscopy. Compared with THD-818 market latex and NSL traditional latex, ASL soap free latex is not added to stabilizer When the dosage of AMPS/NaSS is 1.3%-1.9%, the compressive strength and cementation strength of ASL soap free latex cement is higher. Adding a proper amount of defoamer to ASL latex cement slurry is beneficial to improving the density of latex cement slurry and the compressive strength of cement stone. The suitable dosage of D50 defoamer is 0.8%; ASL-13 When the latex was added to 10%-20%, the latex cement slurry had good performance. The cement stone had high compressive strength and cementation strength; ASL latex cement slurry had a good thickening curve at 70 C C and 90 C C; with the increase of curing temperature (70-C ~ 90 C C) or curing time (1 days to 15 days), the compressive strength of ASL latex cement stone X diffraction analysis and comprehensive thermal analysis show that the hydration products of ASL-13 latex cement and blank cement are very different in the cement body and the interface cementation. In the cement body, ASL-13 latex cement contains latex and more calcium carbonate, and there are more calcium hydroxide in the blank water mud sample. At the boundary surface, ASL-13 latex inhibits the growth of calcium hydroxide crystal at the interface, increases the content of calcium carbonate or ettringite (AFt), and promotes the growth of the hydrogel type hydration products. These hydrated products are beneficial to improve the bonding strength of the interface. The samples of ASL-13 latex cement and the samples of THD-815 latex cement are observed by scanning electron microscopy. There are membrane materials and the surface roughness of ASL latex cement can be significantly reduced. The mechanism of.ASL soap free latex in oil well cement can be divided into two aspects: one is in cement slurry, the traditional latex depends on the van Edward force between emulsifier and cement particles on the surface of cement particles. And ASL soap free latex is a latex particle table. The ionic group formed the ionic bond with the cement particles, and the latex particles adsorbed on the crystal surface to form the space hindrance, which changed the growth rule of the crystal, destroyed the normal growth of the crystal and reduced the volume of the crystallization products, and two in the cement stone, between the ASL latex film and the cement interface. In the form of ionic bond, and in traditional latex cement, the latex film and the cement interface are filled with emulsifier and other substances. So the soap free latex cement shows high compressive strength and cementation strength. The study of the biphasic pre fluid system with good flushing ability for various drilling fluids, the preliquid is thickened at room temperature and high temperature. It has good thermal stability, rheology and suspension stability. The preliquid has good compatibility and stability with the drilling fluid and cement slurry. The mixture of preliquid and ASL latex cement has no adverse effect on the thickening curve of the cement slurry. At the same time, the interface cementation strength is the highest when the biphase preliquid and the ASL latex cement are used. The microsilicon, slag and other active materials participate in the hydration reaction of cement at the interface, which consumes the calcium hydroxide at the interface and increases the expansion of the crystalline products. At the same time, a large number of crystals and gelatinous substances are formed at the cementation interface when the biphase preliquid and ASL latex cement are used, and the cementation quality is improved. These experimental results show that ASL The soapless latex cement has good performance and can improve the bonding strength of the interface remarkably when it is used with the biphasic preposition solution, which is helpful to improve the interlayer sealing ability of the cement ring and improve the cementing quality.

【學位授予單位】：西南石油大學
【學位級別】：博士
【學位授予年份】：2015
【分類號】：TE256

【相似文獻】

相關期刊論文 前10條

1 吳事難;張金龍;丁士東;劉建;;井下泡沫水泥漿密度計算模型修正[J];石油鉆探技術;2013年02期

2 陳軍;孫孝真;;水泥漿[J];西部探礦工程;1993年06期

3 楊貴勝;;水泥漿密度自動控制系統[J];鉆采工藝;1993年03期

4 孫展利,鄧皓;泥漿轉變成水泥漿的室內研究[J];鉆井液與完井液;1994年01期

5 何世明,徐壁華,何平,陳英,宋周成;水泥漿與泥漿比熱的室內研究[J];西南石油學院學報;2000年04期

6 黃柏宗,李寶貴,李希珍,高旭,燕平,高光第;模擬井下溫度壓力條件的水泥漿沉降穩定性研究[J];鉆井液與完井液;2000年02期

7 周芝琴;顧軍;殷洋溢;;低損害水泥漿的研究與應用[J];新疆石油科技;2000年01期

8 鄔鋼;;油井凈水泥漿及水泥石優化措施研究[J];斷塊油氣田;2008年02期

9 楊勇;戴建文;林榮壯;王旭光;;高溫水泥漿沉降穩定性[J];鉆井液與完井液;2010年06期

10 李淑白;耿東士;殷洋溢;趙海濤;;水泥漿對強敏感性砂巖儲層損害評價[J];鉆井液與完井液;2011年06期

相關會議論文 前2條

1 李玉杰;周文彬;步云鵬;聶東;張子鋒;;新型防漏水泥漿在探井中的應用[A];“振興吉林老工業基地——科技工作者的歷史責任”吉林省第三屆科學技術學術年會論文集（上冊）[C];2004年

2 左景欒;吳建光;孫晗森;張平;吳翔;;煤層氣泡沫水泥漿固井技術研究[A];2013年煤層氣學術研討會論文集[C];2013年

相關重要報紙文章 前4條

1 記者 宗鋼　通訊員 周仕明 王其春 譚春勤;工程院研發超高密度水泥漿創世界紀錄[N];中國石化報;2011年

2 特約記者　 呂晶 通訊員　趙曉東;新型水泥漿固井技術成為吐哈油田特色技術[N];中國石油報;2006年

3 田真 王新穎;“封堵可是大有講究的”[N];中國石化報;2014年

4 洪世界;西南油氣田 破超高壓油氣井開發瓶頸[N];中國石化報;2011年

相關博士學位論文 前1條

1 焦利賓;提高界面膠結強度的無皂膠乳水泥和前置液的研究[D];西南石油大學;2015年

相關碩士學位論文 前10條

1 宋保寰;偏心條件下水泥漿二界面的切應力和膠結強度的研究及應用[D];東北石油大學;2015年

2 張韜;可鉆式貼堵工藝技術研究[D];中國石油大學(華東);2014年

3 楊武;應用于低溫固井的低密度減輕材料合成與性能評價[D];西南石油大學;2014年

4 張政;觸變性水泥漿研究[D];西南石油大學;2016年

5 王元慶;控制深水淺層流災害的水泥漿技術研究[D];長江大學;2013年

6 徐永輝;深井水泥水化機理研究[D];大慶石油學院;2007年

7 姜曉超;耐200℃油井水泥漿的研制[D];吉林大學;2012年

8 黃守國;適合于深水鉆井的低熱水泥漿研究[D];長江大學;2012年

9 李玉杰;纖維防漏堵漏水泥漿技術研究[D];大慶石油學院;2008年

10 張維婷;基于SOPC的固井水泥漿密度智能控制方法研究與實現[D];西南石油大學;2011年

，

本文編號：1890474