本文關鍵詞：固井界面微環隙產生機制及計算方法　出處：《中國石油大學學報(自然科學版)》2017年05期 　論文類型：期刊論文

  更多相關文章： 井筒完整性 微環隙 仿真試驗 理論計算 黏結力

【摘要】：針對油氣井生產過程中固井界面微環隙的產生和發展規律進行仿真試驗研究,并對套管-水泥環界面的黏結力進行測量,基于以上研究建立固井界面微環隙的理論計算方法。結果表明:套管內壓過大導致水泥環產生塑性變形,套管內壓減小時固井界面將受拉,實測固井界面存在數量級為0.1 MPa的黏結力,當界面拉力足以克服界面黏結力時,固井界面將會脫離產生微環隙;套管內壓值越大,壓力卸載后產生微環隙的機率越大,且微環隙尺寸越大;相同膠結質量下固井一界面比二界面更容易產生微環隙;理論計算結果與仿真試驗結果具有較好的一致性。
[Abstract]:In view of the formation and development law of cementing interface microannulus in the production process of oil and gas wells, simulation experiments were carried out, and the bond force between casing and cement annulus was measured. Based on the above research, the theoretical calculation method of cementing interface microannular gap is established. The results show that too large casing pressure leads to plastic deformation of cement ring, and the cementing interface will be pulled when casing pressure decreases. The measured cementing interface has a bonding force of 0. 1 MPa. When the interface tension is enough to overcome the interface bond force, the cementing interface will break away from the microannular gap. The greater the pressure in the casing, the greater the probability of producing microannular gap and the larger the size of the microannular gap. At the same cementing quality, the cementing interface is easier to produce microannulus than that of the two interfaces. The theoretical results are in good agreement with the simulation results.
【作者單位】： 中國石油大學石油工程學院;中國石化中原油田分公司石油工程技術研究院;
【基金】：國家自然科學基金項目(51674284) 中央高�；究蒲袠I(yè)務費專項(R1502039A,16CX06035A)
【分類號】：TE256
【正文快照】： An assessment method for occurrence of micro-annular fractureson cementing interfaces of oil and gas well casingZHAO Xiaofeng1,2,GUAN Zhichuan1,SHI Yucai1,LI Tao1,LIAO Hualin1,JIANG Jinxing1,SUN Baojiang1(1.School of Petroleum Engineering in China Univer

【相似文獻】

相關期刊論文 前4條

1 池英柳，，陳憲侃;雁翎油田注入氮?dú)庋匚h(huán)隙竄流的可能性分析[J];石油大學學報(自然科學版);1994年01期

2 步玉環;沈兆超;王銀東;萬春浩;毛廣良;;固井第一界面微環隙對聲波傳播規律的影響[J];石油鉆探技術;2014年01期

3 朱海燕;趙軍;鄧金根;趙琥;;水力壓裂過程中微環隙的產生和擴展的數值模擬[J];計算機輔助工程;2013年S2期

4 袁仕俊;王天雨;范文同;郭喜純;李進福;金鑫;;微環隙對CBL/VDL測井曲線的影響分析[J];長江大學學報(自然科學版);2012年12期

相關碩士學位論文 前1條

1 沈兆超;固井一界面微環隙識別技術研究[D];中國石油大學(華東);2014年

本文編號：1397637