發布時間：2018-05-18 15:55

  本文選題：軟磁復合材料 + 永磁同步電動機　； 參考：《沈陽工業大學》2017年碩士論文

【摘要】：軟磁復合材料(SMC材料)在最近十幾年得到了飛速發展,并且在許多領域得到了應用。和硅鋼片材料不同,SMC材料電阻率高,磁、熱各向同性,渦流損耗小、可以直接模壓成型,但磁滯損耗較大,所以要推廣商業應用必須研究SMC材料區別于硅鋼片的損耗特性,讓它應用在最適合的工況下,才能發揮其優勢。本課題來自于國家自然科學基金項目——軟磁復合材料的圓筒形直線電機推力波動與材料鐵耗特性研究。本文通過理論和實驗對SMC材料磁特性,SMC材料永磁同步電機鐵耗特性等關鍵問題展開了深入研究。首先使用BROCKHAUS硅鋼測量裝置對SMC材料的環形試樣的磁特性進行了測量。對SMC材料與DW470磁性能的對比分析,進一步說明了SMC材料的優勢與不足,為SMC材料電機的設計提供了參考依據。其次設計出了兩臺分別以SMC材料和DW470為鐵心的永磁同步電機,使用有限元方法計算對比了兩臺樣機空載磁場分布和氣隙磁密,分析出了SMC材料磁導率較低對電機磁場帶來的影響。然后通過負載試驗,得到在同頻率下兩臺樣機效率的變化規律。最后,對SMC不同頻率下的損耗曲線進行非線性回歸分析,得到SMC材料的磁滯損耗、渦流損耗、附加損耗系數。然后通過有限元方法,根據定子鐵心不同區域磁場的變化規律,綜合考慮電機中交變和旋轉磁場的影響,對兩臺樣機的磁滯、渦流損耗以及總的鐵耗進行了分析對比,并驗證了SMC材料在高頻情況下的優越性。
[Abstract]:Soft magnetic composite material (SMC) has been developed rapidly in recent years and has been applied in many fields. Different from silicon steel sheet material, the material has high resistivity, magnetic, thermal isotropy, low eddy current loss, and can be molded directly, but the hysteresis loss is large, so it is necessary to study the loss characteristics of SMC material different from silicon steel sheet in order to promote commercial application. Let it be applied in the most suitable operating conditions, can play its advantages. This topic comes from the research of thrust fluctuation and iron loss characteristics of cylindrical linear motor for soft magnetic composite material, which is a project of National Natural Science Foundation. In this paper, the magnetic properties of SMC materials and the characteristics of iron loss of PMSM are studied in theory and experiment. The magnetic properties of annular samples of SMC materials were measured by BROCKHAUS silicon steel measuring device. The comparative analysis of the magnetic properties of SMC and DW470 further explains the advantages and disadvantages of SMC materials and provides a reference for the design of SMC motors. Secondly, two permanent magnet synchronous motors (PMSM) with SMC and DW470 as the core are designed, and the no-load magnetic field distribution and air-gap magnetic density of the two prototypes are calculated and compared by finite element method. The influence of low permeability of SMC material on the magnetic field of motor is analyzed. Then through the load test, the variation law of efficiency of two prototypes at the same frequency is obtained. Finally, the nonlinear regression analysis of the loss curves at different frequencies of SMC is carried out, and the hysteresis loss, eddy current loss and additional loss coefficient of SMC materials are obtained. Then the hysteresis, eddy current loss and total iron loss of the two prototypes are analyzed and compared by the finite element method, according to the variation rule of magnetic field in different regions of stator core, and considering the influence of alternating and rotating magnetic field in the motor, the magnetic hysteresis, eddy current loss and total iron loss of the two prototypes are analyzed and compared. The superiority of SMC in high frequency is verified.
【學位授予單位】：沈陽工業大學
【學位級別】：碩士
【學位授予年份】：2017
【分類號】：TM341

【參考文獻】

相關期刊論文 前10條

1 張志東;;磁性材料的磁結構、磁疇結構和拓?fù)浯沤Y(jié)構[J];物理學報;2015年06期

2 張繼鵬;蘇錦智;付榮華;邊長安;;高速交流永磁發電機定子鐵心損耗計算[J];微電機;2014年11期

3 李盛雄;張經緯;;中高頻條件下三種鐵耗計算方法的對比分析[J];船電技術;2014年06期

4 孫紅超;劉文輝;王富春;;高效電機設計方法的研究[J];防爆電機;2014年02期

5 袁琦;黃建清;;基于軟磁復合材料的新型直線電動機研究[J];微特電機;2010年12期

6 羅應立;趙海森;姚丙雷;陳偉華;;交流電機鐵耗的工程計算方法分析[J];電機與控制應用;2010年11期

7 趙海森;羅應立;劉曉芳;Ren.H Wang;陳偉華;;異步電機空載鐵耗分布的時步有限元分析[J];中國電機工程學報;2010年30期

8 鄧秋玲;黃守道;許志偉;彭磊;;軟磁復合材料在軸向磁場永磁風力發電機中的應用[J];微特電機;2010年01期

9 莫會成;閔琳;于志剛;余寒峰;;電機用硅鋼片鐵耗研究[J];微電機;2008年11期

10 黃允凱;朱建國;胡虔生;;采用軟磁復合材料設計高速爪極式永磁電機[J];電機與控制應用;2007年12期

，

本文編號：1906463